Influences of P-N-containing Inhibitor and Memory Effect on PCDD/F Emissions During the Full-Scale Municipal Solid Waste Incineration

Yunfeng Ma,Xiaoqing Lin,Zhiliang Chen,Xiaodong Li,Shengyong Lu,Jianhua Yan

DOI: https://doi.org/10.1016/j.chemosphere.2019.04.161

IF: 8.8

2019-01-01

Chemosphere

Abstract:Influence of inhibition and memory effect on PCDD/Fs are carried out in a full-scale (23 t h(-1)) municipal solid waste (MSW) incinerator under three conditions. Ammonium dihydrogen phosphate (ADP) is injected into the post combustion zone of incinerator. The results show that the inhibition efficiency of PCDD/Fs in flue gas was 53.34% (71% for TEQ), and ADP possibly also didn't have effect on the chlorination reaction of PCDD/F formation. The memory effect phenomenon, PCDD/F adsorption/desorption, is clearly discovered in the wet scrubber system (WSS), resulting in PCDD/F concentration increased by 6.2 -19.9 times. Memory effect also changes the distribution of PCDD/Fs by increasing the proportions of low-chlorinated PCDD/Fs, which is easily to be desorbed because of their higher vapor pressure comparing with the high-chlorinated PCDD/Fs. After renewing the scrubbing solution and cleaning the bottom sludge in WSS, the PCDD/F TEQ concentrations decreases from 0.51 to 0.24 ng I-TEQ Nm(-3), further mitigating but still not enough to eliminate the memory effect because the PCDD/F desorption of wall and scrubber fillings in the WSS. The results are paving the way for further industrial optimized design of WSS and assist in controlling the PCDD/F emissions from MSWI. (C) 2019 Elsevier Ltd. All rights reserved.