Abstract:Deep-sea mud has received significant attention from the international community as a novel resource of rare earth elements (REEs). In this study, a novel approach is proposed for the recovery of REEs from deep-sea mud. The mud samples were characterized, and the occurrence states of REEs were clarified. The results revealed that REEs in mud occur almost entirely in hydroxyapatite minerals, which can be easily reached via acid leaching. The optimized leaching percentage of REEs reaches 89.50 %, 88.94 %, 83.81 %, and 86.52 %, respectively, by using 2.0 mol/L HCl, 2.0 mol/L HNO 3 , 1.0 mol/L H 2 SO 4 , and 2.0 mol/L H 3 PO 4 as leaching agents with a liquid–solid ratio of 4:1 and a stirring speed of 300 r/min at 60 °C for 30 min. After that, the REEs were leached into the leaching solution along with the impurities of Al, Fe, Mn, Ca, and Mg. The sulfate leaching solutions were directly used for solvent extraction of REEs using N1923 and TBP. A total of 97.50 % REEs and 100 % Fe were co-extracted through five-stage countercurrent extraction using an organic system consisting of 10 %(v/v) N1923 and 10 %(v/v) TBP in sulfonated kerosene at an O/A ratio of 1:1.4. In contrast, the percentage extraction of other metals was negligible. Furthermore, 99.33 % REEs in the loaded organic system were selectively stripped through a five-stage countercurrent stripping process using the (0.1 mol/L HCl + 4.9 mol/L NaCl) solutions with an O/A ratio of 1:1, leaving Fe in the organic system. The remaining Fe-loaded organic material could be stripped using a 0.5 mol/L HNO 3 solution followed by Na 2 CO 3 neutralization for regeneration. Finally, 98.81 % of the REEs in the stripped solution were precipitated through Na 2 C 2 O 4 precipitation followed by calcination at 900°Cfor 120 min. Throughout the entire separation and purification process, 80.20 % of REEs in the deep-sea mud resource were recovered as pure enrichment of REEs oxide with a content of 81.82 %, while Al, Fe, Mg, Ca, Mn, and P were less than 0.15 %.

Recovery of Iron and Rare Earth Elements from Red Mud Through an Acid Leaching-Stepwise Extraction Approach

Selective Removal of Iron from Acid Leachate of Red Mud by Aliquat 336

Selective extraction of rare earth elements from red mud using oxalic and sulfuric acids

Extraction of Al and rare earths (Ce, Gd, Sc, Y) from red mud by aerobic and anaerobic bi-stage bioleaching

Recovery of rare earth elements from deep-sea mud using acid leaching followed by selective solvent extraction with N1923 and TBP

Enhanced Selective Leaching of Scandium from Red Mud

Stripping of Fe(III) from Aliquat 336 by NaH2PO4: Implication for Rare-Earth Elements Recovery from Red Mud

Separation and Recovery of Iron and Scandium from Acid Leaching Solution of Red Mud Using D201 Resin

Overview On Extraction and Separation of Rare Earth Elements from Red Mud: Focus on Scandium

Separation and Recovery of Scandium and Titanium from Red Mud Leaching Liquor Through a Neutralization Precipitation-Acid Leaching Approach

Efficient Selective Extraction of Scandium from Red Mud

Extraction of Scandium and Iron from Red Mud

A novel process for recovery of aluminum, iron, vanadium, scandium, titanium and silicon from red mud

Selective extraction of scandium from bauxite residue (red mud) utilizing iron sulfate roasting followed by water leaching

Stepwise leaching of valuable metals from red mud using hydrochloric acid

Stepwise extraction of valuable components from red mud based on reductive roasting with sodium salts

Comprehensive examination of acid leaching behaviour of mineral phases from red mud: Recovery of Fe, Al, Ti, and Si

Research on High-Pressure Hydrochloric Acid Leaching of Scandium, Aluminum and Other Valuable Components from the Non-Magnetic Tailings Obtained from Red Mud after Iron Removal

Extraction of Valuable Metals from Red Mud

Recovery of Scandium from Leachate of Sulfation-Roasted Bayer Red Mud by Liquid–Liquid Extraction

A Comparison Study on the Recovery of REEs from Red Mud by Sulfation Roasting–Water Leaching and Citric Acid Leaching