Abstract:Because methanol can be synthesized from captured CO2 and green H2, it is a promising alternative fuel for reducing carbon emissions from heavy-duty vehicles. Experiments were conducted on a multi-cylinder port fuel injection spark-ignition (SI) heavy-duty pure methanol engine modified from a natural gas engine. The main objective was to evaluate the performance of a heavy-duty SI pure methanol engine and its improvement over the original natural gas engine. The effects of the exhaust gas recirculation (EGR) rate and spark timing on the brake thermal efficiency (BTE), as well as the NOx, CO and HC emissions, were investigated under a wide range of operating conditions. The experimental results indicated that the pure methanol engine had a BTE of > 40% BTE in a brake mean effective pressure (BMEP) range of 1.27-2.17 MPa at speeds ranging from 1000 to 1700 rpm and that the peak BTE was ~ 41.4%, which was higher than that of the original natural gas engine by an absolute 3%. The EGR tolerance of methanol engine was high and the coefficient of variation of the indicated mean effective pressure (COVIMEP) could be maintained below 2%, even at 31% EGR. With an increase in the EGR rate, the CO emissions first decreased and then increased. The partial oxidation of unburned methanol contributed to higher CO emissions when the EGR rate reached a critical value. Advancing the spark timing increased the HC emissions at a low EGR because of the lower post-oxidation temperature; however, it reduced the HC emissions at a high EGR rate because of the more stable combustion. At a BMEP above 0.87 MPa, the NOx, HC and CO emissions ranged from 0.055 to 1.185 g/kWh, from 2.4 to 13.05 g/kWh, and from 6.36 to 10.88 g/kWh, respectively. The pure methanol engine had lower NOx and CO emissions but higher HC emissions than the original natural gas engine.

Study on the Performance of Methanol Engine

Engine Performance and Emissions of A Compression Ignition Engine Operating on the Diesel-Methanol Blends

Combustion and Emission Characteristics of a DI Diesel Engine Fueled by Diesel-Methanol Blends

Experimental Evaluation of Performance of Heavy-Duty SI Pure Methanol Engine with EGR

Study on Carbonyl Compounds Emissions from a Methanol Engine

Effects of Methanol/Gasoline Blends on a Spark Ignition Engine Performance and Emissions

Experimental Investigation of Diluents Components on Performance and Emissions of a High Compression Ratio Methanol SI Engine

Study on the Emission Characteristic of Methanol-Gasoline Blend Fuel on EFI Engine

Improvement of Performance and Emissions of a Compression Ignition Methanol Engine with Dimethyl Ether

Study on Combustion Characteristics of a DI Diesel Engine Operating on Diesel/Methanol Blends

Experimental Investigation on the Emissions of a Port Fuel Injection Spark Ignition Engine Fueled with Methanol–Gasoline Blends

Performances of electronic fuel injection engine fueled with methanol-gasoline blended fuel

Experimental Study on Combustion and Emission Characteristics of a Lean Burn Engine Fueled with Methanol/Gasoline

Experimental Study on Ammonia-Methanol Combustion and Emission Characteristics in a Spark Ignition Engine

Investigation on mixture formation and combustion characteristics of a heavy-duty SI methanol engine

Study of SI Engine Fueled with Methanol Vapor and Dissociation Gas Based on Exhaust Heat Dissociating Methanol

Aldehydes and Methanol Emission Mechanisms and Characteristics from A Methanol/Gasoline-Fueled Spark-Ignition (si) Engine

Experimental investigation on exhaust emissions of a heavy-duty vehicle powered by a methanol-fuelled spark ignition engine under world Harmonized Transient Cycle and actual on-road driving conditions

Experimental study of effects of exhaust gas recirculation and combustion mode on combustion, emission, and performance of DME‐methanol ‐fueled turbocharged c ommon‐rail engine

Effects of Methanol Diesel Blends on Performance and Emissions of a Diesel Engine

Comparative study on combustion and emission characteristics of methanol/hydrogen, ethanol/hydrogen and methane/hydrogen blends in high compression ratio SI engine