Abstract:Capacitive deionization (CDI), an emerging method to eliminate ions from water at a low cost, has garnered significant interest in recent years. This study evaluates the implication of cation exchange resin loading on the membrane via the nonsolvent-induced phase inversion method. After determining the quantity of resins efficiently loaded on the membrane, it was subsequently utilized as a cation exchange membrane in the membrane capacitive deionization (MCDI) unit to examine the performance removal of Ni 2+ . The results show that the amount of resins influenced the membrane structure and significantly improved the efficiency of Ni 2+ removal. The sulfonic acid group show a strong intensity directly proportional to the quantity of resins based on the FTIR measurement. In conjunction with the enhanced resin amount, ion exchange capacity and water content were increased. Simultaneously, there was an observed elevation in the water contact angle and the roughness of the membrane surface with increased resin amount. In the MCDI unit, membrane M20 (20% by weight resin) was employed to elucidate its roles in the CDI unit, encompassing an examination of various concentrations and flow rates, with Ni 2+ utilized as a test contaminant. The results demonstrated that using membrane M20 in the MCDI (MCDI-M20) unit consistently exhibited higher adsorption levels than the CDI unit, reaching 19.80 mg g −1 ACC in the MCDI-M20 unit, while CDI unit achieved 10.27 mg g −1 ACC at 200 mg L −1 Ni 2+ concentration and a flow rate of 10 mL min −1 at 1.2 V. Additionally, Ni 2+ concentrations and flow rates in CDI system had an evident impact on the duration of adsorption due to the mechanisms of ions transport on the membrane. This study suggests that employing the prepared membrane in the MCDI unit enhanced the removal of Ni 2+ from the solution, contributing to sustainable development goals.

Study on Conductivity of Ion-exchange Resin Packed in Continuous Electrodeionization(CEDI)

Study on the performance of EDI device in dealing with Ni2+solution with dilute departments filled with cation exchange resins

Influence of ion exchange resin on the performance of continuous electrodeionization (CEDI) treating low-level radioactive wastewater

Low-level Radioactive Wastewater Treatment by Continuous Electrodeionization

Removal of Trace Cs(I), Sr(II), and Co(II) in Aqueous Solutions Using Continuous Electrodeionization (CEDI)

Effect of ion exchange membrane on the removal efficiency of continuous electrodeionization (CEDI) during low level radioactive wastewater treatment

Study on Properties of Ion-Exchange Resin Packed in Continuous Electrodeionization for the Treatment of Borated Wastewater

SCALING PROBLEM AND PREVENTING MEASURES OF ELECTRODEIONIZATION PROCESS

Removal of Co2+and Sr2+from a Primary Coolant by Continuous Electrodeionization Packed with Weak Base Anion Exchange Resin

Continuous electrodeionization for removal and recovery of Cr(VI) from wastewater

Variable effects on the performance of continuous electrodeionization for the removal of Cr(VI) from wastewater

Simultaneous Removal of Nitrate and Hardness Ions from Groundwater Using Electrodeionization

Separation and Recovery of Cr(Iii) and Cr(Vi) Using Electrodeionization As an Efficient Approach

Membrane-free Electrodeionization for Purification of Wastewater Containing Low Concentration of Nickel Ions

Advancing electrodeionization with conductive ionomer binders that immobilize ion-exchange resin particles into porous wafer substrates

Numerical simulation of the electrodeionization (EDI) process for producing ultrapure water

Preparation of heterogeneous cation exchange membrane and its contributions in enhancing the removal of Ni 2+ by capacitive deionization system

ENHANCING COPPER REMOVAL THROUGH INTEGRATED CAPACITIVE DEIONIZATION WITH HETEROGENEOUS CATION EXCHANGE MEMBRANE

Influence of Some Parameters on Membrane-Free Electrodeionization for the Purification of Wastewater Containing Nickel Ions

An energy efficient hybrid membrane technique for the removal of toxic metals from aquatic environment

Electrodialysis for the Volume Reduction of the Simulated Radionuclides Containing Seawater.