Abstract:Rolling bearings play a critical role in wind turbine generators, operating continuously in an electromagnetic excitation environment. Their fault vibration characteristics are affected by unbalanced magnetic pull (UMP), which has received little attention in previous studies. Moreover, torsional vibration can provide advantages in bearing fault diagnosis, since it has a good signal-to-noise ratio (SNR) and it can be easily measured by the encoder. However, torsional vibration is rarely considered in the existing model of wind turbine generator. Accordingly, this paper proposes a dynamic model with 8 degrees of freedom to analyze the bearing outer ring fault characteristics of wind turbine generator under the influence of UMP, while also taking into account the torsional vibration in the model. The validity of the model is verified through experiments conducted on a test rig. The results displays modulation of the ball pass frequency outer (BPFO) harmonics with both UMP frequency and rotation frequency in lateral vibration, and this phenomenon can also be observed in instantaneous angular speed (IAS) and instantaneous angular acceleration (IAA) signals that represent torsional vibration. Besides, the lateral vibration spectrum reveals two distinct resonance bands, and simulation analysis suggested that the rotor and bearings give rise to low-frequency and high-frequency resonance, respectively. This study provides a reference for bearing faults diagnosis in wind turbine generator.

Modeling and Mechanism of Torsional Vibration of Grid-Connected Wind Generator

Model and Principle of Stalled Wind Turbine for Torsional Vibration Studies

Analysis of Flexural and Torsional Vibration for Turbogenerator Shafts on Power Impact

Torsional Vibration Characteristic Study of the Grid-Connected Dfig Wind Turbine

Time-frequency Analysis on Torsional Vibration of Turbo-generator Shafts

Torsional Vibration of a Shafting System under Electrical Disturbances

Modeling and Simulation of DFIG for Torsional Vibration

Small-signal Modeling and Modal Analysis of Wind Turbine Based on Three-mass Shaft Model

Modeling and Simulation of Shaft Torsional Vibration in Wind Farm Composed of Fixed Speed Inductive Generators

Small Signal Modeling and Simulation for Torsional Vibration of Wind Farms

Small Signal Modeling and Stability Analysis of A Dfig Based Wind Power System under Unbalanced Grid Voltage Condition

Small Signal Stability Analysis of Wind Turbine for Shaft Torsional Vibration Studies

TORSION VIBRATION ANALYSIS AND EQUIVALENT MODEL OF WIND FARM

Study on modeling and simulation of non-grid-connected wind turbine

Coupled Torsional Vibration and Fatigue Damage of Turbine Generator Due to Grid Disturbance

Torsional and lateral vibration analysis of wind turbine generator bearing outer ring fault considering unbalanced magnetic pull

An Equivalent Model of Wind Farms for Torsional Vibration Analysis

Shafting Torsional Vibration Characteristics Analysis of the PMSG-Based Wind-Driven System

Modeling Principle and Parameter Identification of Double Fed Wind Turbine for Electromechanical Transient Simulation of Power System

An Integrated Electromechanical Model of the Fixed-Speed Induction Generator for Turbine-Grid Interactions Analysis

Modeling and Analysis of Direct-drive Permanent Magnet Synchronous Wind Generation System