Abstract:The condensation heat and mass transfer of steam-He, steam-N2 and steam-CO2 mixtures on a horizontal tube under free convection was studied experimentally and theoretically. A model was developed to predict the total condensation heat transfer coefficient of these mixtures and the model considered the effects of suction, fog formation and the variation of the mixture density and molecular weight across the diffusion layer. The experiments were conducted to investigate the effects of noncondensable gas component, concentration and surface subcooling. The condensation heat transfer coefficients are significantly reduced due to the presence of noncondensable gases. The condensation heat transfer coefficient decreases slowly as the surface subcooling increases and the subcooling effect decreases with increasing noncondensable gas concentration. For a given noncondensable gas mole fraction and a given surface subcooling, the steam-He mixture has the highest measured condensation heat transfer coefficient, followed by the steam-N2 mixture and the steam-CO2 mixture has the lowest measured condensation heat transfer coefficient. But for a given noncondensable gas mass fraction and a given surface subcooling, the measured condensation heat transfer coefficient of the steam-He mixture is the lowest, followed by the steam-N2 mixture, CO2 mixture. The model predicts the relative errors of the total condensation heat transfer coefficients of these mixtures within ±30%. A condensation heat transfer correlation was developed based on the experimental data and the correlation achieved an uncertainty of less than 20%.

Liquid level angle of condensate in horizontal tube

Experimental study on heat transfer characteristics of vapor flow condensation in horizontal tube in vacuum mode

Experimental Study on Condensation of Steam/air Mixture in a Horizontal Tube

Experimental Study on Condensation of High-Pressure Steam in A Horizontal Tube with Pool Boiling Outside

Condensation Heat Transfer of Steam on Vertical Micro-Tubes

Numerical Investigation of Convective Condensation with the Presence of Non-Condensable Gases in A Vertical Tube

Experimental study on direct contact condensation of stable steam jet in water flow in a vertical pipe

Experimental and theoretical investigation on condensation inside a horizontal tube with noncondensable gas

Experimental Investigation on Condensation Heat Transfer and Pressure Drop of High Saturation Temperature Organic Fluid in a Horizontal Smooth Tube

Theoretical Modeling of Vapor Condensation in the Presence of Noncondensable Gas on a Horizontal Tube

Vapor Condensation with Low Air Mass Fraction Inside Water Seal Branch Tube under Free Convection

Experimental Study of Air-Steam–Mixture Condensation Underneath Containment Vessel Surface

Condensation heat and mass transfer of steam with non-condensable gases outside a horizontal tube under free convection

Theoretical Study on Condensation in Horizontal Tubes with Noncondensable Gas

Experimental Investigation on the Condensation Patterns and Pressure Oscillation Characteristics of Steam Submerged Jet Through a Horizontal Pipe at Low Steam Mass Flux

VACUUM CONDENSATION IN AN INCLINED FLAT TUBE: HEAT TRANSFER AND PRESSURE DROP

Study of Condensation Flow Patterns and Heat Transfer Characteristic on A Horizontal Tube Bundle

Experimental Research on Condensation Outside A Horizontal Tube at Low Mass Fluxes

Numerical Simulation Of Laminar Film Condensation In A Horizontal Minitube With And Without Non-Condensable Gas By The Vof Method

Numerical Investigation of Air-Steam Condensation in a Vertically Enhanced Tube with Concave and Convex Surfaces

Experimental investigation on interface characteristics and heat transfer during bubble condensation in narrow rectangular channel