Abstract:In this study, ozone catalysts (hydrogenation-modified red mud, HM-RM) successfully prepared by hydrogenation-modification of industrial hazardous solid waste red mud (RM) as a raw material in accordance with the viewpoint of treating waste with waste and using waste. Meanwhile, as for the common phenomenon of membrane fouling, uneven distribution of multiphase solid catalysts and ozone in liquids, the addition of ultrasound can not only disperse materials, but also play a role in online cleaning of ceramic membranes and catalysts. The optimum treatment conditions for Rhodamine B (RhB) solution with volume of 2 L and concentration of 40 mg/L were catalyst concentration of 0.4 mg/L, reaction temperature of 45 °C, ultrasonic time of 1 h, ultrasonic intensity of 600 W, removal rate of RhB was up to 90 %. In addition, the computational fluid dynamics (CFD) simulation method was used to investigate the fluid flow between the two gas-liquid phases and the effect of the negative pressure of the membrane pump on the fluid by the analysis of flow, pressure and ozone flux of the ceramic membrane(CM) reaction apparatus. The CFD simulation results showed that at the inlet gas-liquid flow rate of 3 m/s and the negative pressure of 20,000 Pa, the maximum flow rates of CM-1 were 3 m/s, 0.752 m/s for CM-2, and 0.228 m/s for CM-3, respectively. Vortices, which are beneficial to solid-liquid mixing and gas-liquid mass transfer, formed between the suction port CM-1 of CM-1 and the inlets of CM-2 and CM-3. This discovery is consistent with relevant experimental research results. Significantly higher concentrations of both •OH and dissolved ozone were observed in the US/HM-RM/O3 system compared to other systems, indicating the significant improvement in ozone utilization rate through the application of ultrasound. The superiority of the US/HM-RM/O3 device was demonstrated. The real dye effluent was tested under optimum operating conditions and the results showed that COD and TOC were reduced by 81.34 % and 60.23 % respectively after 180 min of treatment. The above research can provide technical support for the treatment of dye wastewater using Ultrasound-enhanced ozone oxidation ceramic membranes.

A Systematic Study of Enhanced Ozone Mass Transfer for Ultrasonic-Assisted PTFE Hollow Fiber Membrane Aeration Process

Bubbleless Membrane Contactor for Enhanced Ozone Mass Transfer and Ozonation for Water Purification

The enhancement of ozone–liquid mass transfer performance in a PTFE hollow fiber membrane contactor using ultrasound as a catalyzer

Fabrication of High-Flux PTFE Hollow Fiber Membranes Through Nonionic Surfactant Infiltration Coupled with Mussel-Inspired Chemistry Coating

Process intensification of the ozone-liquid mass transfer in ultrasonic cavitation-rotational flow interaction coupled-field: Optimization and application

Intensification of Gas–Liquid Mass-Transfer Efficiency by Introducing a Superaerophilic Surface in the Ozonation Process

Enhanced Mitigation of Membrane Fouling and Degradation of Perfluorooctanoic Acid in the Treatment of Natural Surface Water Through the Application of Dielectric Barrier Discharge/sulfite

Improved Ultrafiltration Performance Through Dielectric Barrier Discharge/sulfite Pretreatment: Effects of Water Matrices and Mechanistic Insights

STUDY ON AN INTEGRATED PROCESS OF OZONATION-COAGULATION-PTFE HOLLOW FIBER MEMBRANE FILTRATION

Ozone Mass Transfer Behaviors on Physical and Chemical Absorption for Hollow Fiber Membrane Contactors.

Ozone Micro-Bubble Aeration Using the Ceramic Ultrafiltration Membrane with Superior Oxidation Performance for 2, 4-D Elimination

Coagulation–bubbling–ultrafiltration: Effect of Floc Properties on the Performance of the Hybrid Process

Ozone membrane contactors for water and wastewater treatment: A critical review on materials selection, mass transfer and process design

Ozone micro-bubble aeration using the ceramic ultrafiltration membrane with superior oxidation performance for 2,4-D elimination

Enhancement of Ozone Mass Transfer by Stainless Steel Wire Mesh and Its Effect on Hydroxyl Radical Generation

IMPACTS OF ULTRASOUND ON MASS TRANSFER DURING OZONE DISINFECTION PROCESS

Study on Micro-polluted Water Treatment by Ozone/Ceramic Membrane and Membrane Fouling

Optimization of Hydrophilic Modification Process for PTFE Microfiltration Membrane

Using a membrane contactor for ozone mass transfer study and model dye wastewater treatment

Continuous ultrasonic ozone coupling technology-assisted control of ceramic membrane fouling coupled enhanced multiphase mixing to treat dye wastewater and CFD flow field simulation

Combined Water Flux Enhancement of PES-based TFC Membranes in Ultrasonic-Assisted Forward Osmosis Processes