Abstract:Short particle residence time in the active area limits the engineering applications of impinging stream reactors. The single-particle residence time in the active area (t(tot)) is measured and compared among impulse impinging streams (IIS) in which both inlet velocities exhibit step variations during one period, asymmetric impinging streams (AIS) and symmetric impinging streams (SIS). In addition, the effects of the impulse inlet velocity conditions, the reactor geometry and the particle properties on the single-particle motion behaviors and trajectories in a coaxial impinging stream reactor are investigated and discussed in this study. T denotes the variation period of the impulse inlet flows. The results show that single particles with different particle relaxation time (tau*) exhibit different motion behaviors in an impinging stream reactor. A single particle with a short tau* is accelerated directly by the original fluid and leaves the active area without oscillatory motion in SISAIS and IIS. A single particle with a long tau* exhibits at most three oscillatory motions in SIS,AIS and IIS. However, a single particle with an even longer tau* exhibits only three oscillatory motions in SIS and AIS but at least three oscillatory motions in IIS. The t(tot) value in a coaxial impinging stream reactor generally varies with the inlet velocity conditions, the properties of the particles themselves and the size of the active area. In particular, at long tau*, the t(tot), value reaches a maximum in the IIS case when T = T-b. T-b is determined by tau*, Re-m and L/D. By contrast, at short tau*, the t(tot) values in SISIIS and AIS are all the same. However, at long tau*, the value of t(tot) is greater in the case of IIS at T = T-b than it is in the AIS case, increases with a decreasing inlet velocity ratio in the AIS case, and is the shortest in the SIS case under identical simulation conditions. On the whole, at long tau*, t(tot) and the particle motion distance in the active area can be significantly enhanced in the IIS case in comparison with the SIS and AIS cases at the same mean inlet velocity by reasonably designing the inlet velocity conditions. (C) 2018 Elsevier B.V. All rights reserved.

Experimental and Numerical Studies on Flow and Turbulence Characteristics of Impinging Stream Reactors with Dynamic Inlet Velocity Variation

Flow Simulation and Experimental Study of a Dynamic Asymmetric Impinging Stream

Numerical Simulations of a Gas–Solid Two-Phase Impinging Stream Reactor with Dynamic Inlet Flow

Experimental Study on the Influence of Velocity on Hydraulic Characteristics in Reactor Lower Plenum

Experimental Study on Turbulence Properties in the Dual Nozzle Opposed Impinging Stream Mixer

Effects of Non-Uniform Inflow on the Spatial and Temporal Distribution of Impeller Excitation in Axial Flow Pumps in Water Tunnels

Experimental Study of Flow Regimes in Three‐dimensional Confined Impinging Jets Reactor

Effects of inlet turbulence intensity on wall heat transfer in a turbine guide vane

Study of Single-Particle Residence Time in Impulse, Symmetric and Asymmetric Coaxial Impinging Streams

Complexity Analysis of Multiscale Flow Field of Dynamic Impinging Stream based on Chaos Theory and Stockwell Transform

Structure optimization and flow field characteristics of baffle-type impinging stream reactor

A Study on Intermittency Phenomena in the Impeller Stream Via Digital Particle Image Velocimetry (DPIV)

Flow regime transition and bubble behavior in gas-liquid two-phase impinging jet reactor

Investigation of effects of impeller geometry on the spatial distribution of turbulent field and micro-mixing performance in a stirred reactor equipped with multiple impellers

Experimental Study of Oscillation Behaviors in Confined Impinging Jets Reactor under Excitation

Numerical simulation of jet impact process with different jet velocities in a negative pressure ambient

Numerical Study Of Flow And Heat Transfer In Rectangular Channel With Periodic Longitudinal Vortex Generators Under Pulsating Flow

NUMERICAL INVESTIGATION OF DIFFERENT TURBULENCE MODELS APPLIED IN COMBINED IMPINGEMENT AND FILM COOLING

Distribution of Particle Resident Time in a Combined Coaxial Gas–solid Two-Phase Impinging Stream

Experimental Study on PIV Measurement and CFD Investigation of the Internal Flow Characteristics in a Reactor Coolant Pump

Three-Dimensional Simulation of Turbulent Rectangular and Square Impinging Jet Flows