Abstract:Thermal non-uniformity in the horizontal mixed convection heat transfer of fluids at the supercritical pressure is a major issue that must be addressed in a trans-critical organic Rankine cycle. However, the heat transfer mechanism is not fully understood. To further investigate the mechanisms of the buoyancy effect and property variations in a horizontal supercritical flow, mixed convection with supercritical pressure R134a is studied numerically herein using the AKN turbulence model. When the buoyancy effect is weak, the difference in the turbulent kinetic energy with k(top) < k(bottom) is the dominating factor resulting in a non-uniform heat transfer. In a strongly buoyancy-affected mixed convection, the flow process is divided into three regions. In region I (T-w increasing section) and region III (gas-like section), k(top) < k(bottom) because of the greater velocity gradient at the bottom; in region 11, where T-w,T-top op reaches a peak and subsequently decreases, k(top) < k(bottom) is observed because the newly developed vortexes near the tube top intensifies the turbulence near the top. Heat transfer cases with various tube diameters and pressures are discussed. A stronger buoyancy effect is developed in larger tubes. No new vortex is formed in a 2-mm tube while multiple vortexes are developed in the upper region of 16-mm and 26-mm tubes, providing stronger turbulence for the heat transfer recovery. As the specific heat is sensitive to the pressure variation while the density variation with pressure is moderate, the pressure has less effect on heat transfer in a strong-buoyancy case than in a weak-buoyancy case. (C) 2019 Elsevier Ltd. All rights reserved.

Buoyancy Effects on Supercritical-Pressure Conjugate Heat Transfer of Aviation Kerosene in Horizontal Tubes

Asymmetric Heating and Buoyancy Effects on Heat Transfer of Hydrocarbon Fuel in a Horizontal Square Channel at Supercritical Pressures

Convection Heat-Transfer Characteristics of Supercritical Pressure RP-3 in Horizontal Microchannels

Large Eddy Simulations and Analyses of Hydrocarbon Fuel Heat Transfer in Vertical Upward Flows at Supercritical Pressures

Numerical Study of Fluid Flows and Heat Transfer of Aviation Kerosene with Consideration of Fuel Pyrolysis and Surface Coking at Supercritical Pressures

HEAT TRANSFER CHARACTERISTICS OF RP-3 KEROSENE AT SUPERCRITICAL PRESSURE IN A VERTICAL CIRCULAR TUBE

Heat Transfer Characteristics of Supercritical Aviation Kerosene at Different Tube Diameters

Conjugate Heat Transfer, Endothermic Fuel Pyrolysis and Surface Coking of Aviation Kerosene in Ribbed Tube at Supercritical Pressure

Large Eddy Simulations of Heat Transfer and Thermal Oxidative Coking of Aviation Kerosene in Vertical U-Tube at a Supercritical Pressure

Numerical Study of Heat Transfer Characteristics of Downward Supercritical Kerosene Flow Inside Circular Tubes

Heat Transfer Performance of Aviation Kerosene RP-3 Flowing in a Vertical Helical Tube at Supercritical Pressure

Heat Transfer Characteristics Of Aviation Kerosene In Vertical Upward High Flux Tubes At Supercritical Pressure

Experimental Study on Heat Transfer of Aviation Kerosene in a Vertical Upward Tube at Supercritical Pressures

Numerical investigations on heat transfer of supercritical RP-3 flowing in circular tube

Numerical Simulation of Convective Heat Transfer Characteristics of Aviation Kerosene Inside Elliptical Tubes under Supercritical Pressure

Modeling and Simulation of Supercritical-Pressure Turbulent Heat Transfer of Aviation Kerosene with Detailed Pyrolytic Chemical Reactions

Experimental study on heat transfer of supercritical kerosene in vertical upward tube

Heat Transfer Characteristics of Aviation Kerosene Flowing in Enhanced Tubes at Supercritical Pressure

Buoyancy Effect on the Mixed Convection Flow and Heat Transfer of Supercritical R134a in Heated Horizontal Tubes

A Numerical Study of Supercritical Forced Convective Heat Transfer of N-Heptane Inside A Horizontal Miniature Tube

Heat Transfer Characteristics of Hydrocarbon Fuel at Supercritical Pressure in Vertical Circular Tubes