Abstract:Previous studies have shown that the two-layer model more accurately predicts hydrogen dispersion than the conventional notional nozzle models without significantly increasing the computational expense. However, the model was only validated for predicting the concentration distribution and has not been adequately validated for predicting the ve-locity distributions. In the present study, particle imaging velocimetry (PIV) was used to measure the velocity field of an underexpanded hydrogen jet released at 10 bar from a 1.5 mm diameter orifice. The two-layer model was the used to calculate the inlet conditions for a two-dimensional axisymmetric CFD model to simulate the hydrogen jet downstream of the Mach disk. The predicted velocity spreading and centerline decay rates agreed well with the PIV measurements. The predicted concentration distribution was consistent with data from previous planar Rayleigh scattering measurements used to verify the concen-tration distribution predictions in an earlier study. The jet spreading was also simulated using several widely used notional nozzle models combined with the integral plume model for comparison. These results show that the velocity and concentration distributions are both better predicted by the two-layer model than the notional nozzle models to com-plement previous studies verifying only the predicted concentration profiles. Thus, this study shows that the two-layer model can accurately predict the jet velocity distributions as well as the concentration distributions as verified earlier. Though more validation studies are needed to improve confidence in the model and increase the range of validity, the present work indicates that the two-layer model is a promising tool for fast, accurate predictions of the flow fields of underexpanded hydrogen jets. (c) 2020 Hydrogen Energy Publications LLC. Published by Elsevier Ltd. All rights reserved. Previous studies have shown that the two-layer model more accurately predicts hydrogen dispersion than the conventional notional nozzle models without significantly increasing the computational expense. However, the model was only validated for predicting the concentration distribution and has not been adequately validated for predicting the velocity distributions. In the present study, particle imaging velocimetry (PIV) was used to measure the velocity field of an underexpanded hydrogen jet released at 10 bar from a 1.5 mm diameter orifice. The two-layer model was the used to calculate the inlet conditions for a two-dimensional axisymmetric CFD model to simulate the hydrogen jet downstream of the Mach disk. The predicted velocity spreading and centerline decay rates agreed well with the PIV measurements. The predicted concentration distribution was consistent with data from previous planar Rayleigh scattering measurements used to verify the concentration distribution predictions in an earlier study. The jet spreading was also simulated using several widely used notional nozzle models combined with the integral plume model for comparison. These results show that the velocity and concentration distributions are both better predicted by the two-layer model than the notional nozzle models to complement previous studies verifying only the predicted concentration profiles. Thus, this study shows that the two-layer model can accurately predict the jet velocity distributions as well as the concentration distributions as verified earlier. Though more validation

Measurements of Concentration Decays in Underexpanded Jets Through Rectangular Slot Nozzles

Modeling of underexpanded hydrogen jets through square and rectangular slot nozzles

Validation of a Reduced-Order Jet Model for Subsonic and Underexpanded Hydrogen Jets

Comparison of Two-Layer Model for Hydrogen and Helium Jets with Notional Nozzle Model Predictions and Experimental Data for Pressures Up to 35 MPa

Experimental investigation on the microscopic characteristics of underexpanded transient hydrogen jets

Self-similar Characteristics of Underexpanded, Cryogenic Hydrogen and Methane Jets

Comparison of Two-Layer Model for High Pressure Hydrogen Jets with Notional Nozzle Model Predictions and Experimental Data

Experimental Study on Gas-Liquid Flow Characteristics of Submerged Air Jets

Modeling of cryogenic hydrogen releases

Bubble Statistics in Shallow Angle Plunging Liquid Jets

Characterization of the Spatial Atomic Density Distribution in Gas Jets from Three Different Nozzles

Flame Morphology of Horizontal Jets under Sub-Atmospheric Pressures: Experiment, Dimensional Analysis and an Integral Model

Comparison of numerical and algebraic models of low and high pressure hydrogen jet flows with ideal and real gas models

Measurements of Flow Velocity and Scalar Concentration in Turbulent Multi-component Jets: Asymmetry and Buoyancy Effects

Characterization of Turbulent Jets from High-Aspect-Ratio Rectangular Nozzles

A Numerical Study on the Structure and Dynamics of Fuel-Rich Premixed H2–air Jet Flames above a Divergent Micro-Nozzle

Experimental investigation of rectangular nozzle aspect ratio effects on high-pressure helium leakage characteristics

Multi-Component High Aspect Ratio Turbulent Jets Issuing from Non-Planar Nozzles

Statistical Properties of Turbulent Free Jets Issuing from Nine Differently-Shaped Nozzles

Validation of Two-Layer Model for Underexpanded Hydrogen Jets

Experimental investigation on hydrogen jet flame behavior and temperature distribution with different shapes of outlet