Abstract:One novel lightweight building material was successfully manufactured using magnesium oxysulfate (MOS) cement as binder and foam and/or rice husk as inert fillers in this paper. It behaves much higher specific strength and lower environmental load than normal concretes prepared by Portland cement, natural sand and aggregates. To improve the mechanical strength and water resistance of MOS matrix, three kinds of weak acids were incorporated at low levels. On the basis of the modified MOS matrix, foam, rice husk, and the mixture of foam and rice husk were added at variable dosages as fillers to prepare MOS cement based lightweight materials. Mechanical strength, bulk density and compressive strength/volume deformation of these materials were evaluated after variable wetting-drying cycles. At the same time, phase composition and microstructure of typical samples were studied using X-Ray Diffraction (XRD), Fourier Transform Infrared Spectrometer (FTIR), Optodigital Microscope (OM) and Scanning Electron Microscope (SEM) tests. Experimental results indicated that the addition of 0.5% citric acid by MgO weight can greatly enhance compressive strength and water resistance due to the formation of finer needle-like crystals of 5 x 1 x 7 phase instead of 3 x 1 x 8 phase. The higher incorporation of foam and rice husk decreases bulk density and mechanical properties of MOS cement pastes. With a density of as low as 1000 kg/m(3), the compressive strength of MOS cement based lightweight materials can reach higher than 12 MPa. The wetting-drying treatment leads to a negative effect on both compressive strength and volume stability of these materials, due to the transformation of unreacted MgO into Mg(OH)(2) crystals upon water immersion. On the other hand, the coupling effect of water-swelling and drying-shrinkage induces the formation of micro cracks in specimens. A proper addition of foam bubbles and rice husk presents the better resistance to wetting-drying cycles. Therefore, the MOS cement based lightweight material could be widely applied to inner partition walls and structural component, and its long-term service behavior should be further assessed.

Feasibility Study of Strain Hardening Magnesium Oxychloride Cement-Based Composites

Mechanical properties of high ductile magnesium oxychloride cement-based composites after water soaking

Magnesium Oxychloride Cement-Based Strain-Hardening Cementitious Composite: Mechanical Property and Water Resistance

Development of Reactive MgO Cement-Silica Fume–Based Strain-Hardening Engineered Cementitious Composite

Preparation and mechanical characterization of multi-functional high-ductility engineered magnesium oxysulfate cement-based composites

Mechanical Properties and Carbonation Durability of Engineered Cementitious Composites Reinforced by Polypropylene and Hydrophilic Polyvinyl Alcohol Fibers

Experimental Study on Strength Development Pattern of Magnesium Oxychloride Cement Cured in Chloride Solution

Magnesium phosphate cement-based engineered cementitious composites with polyethylene fibers: Performance improvement and design method

Strain hardening magnesium-silicate-hydrate composites (SHMSHC) reinforced with short and randomly oriented polyvinyl alcohol microfibers

Multiscale Investigation on the Performance of Engineered Cementitious Composites Incorporating PE Fiber and Limstone Calcined Clay Cement (LC 3 ).

Preparation of Low-Cost Magnesium Oxychloride Cement Using Magnesium Residue Byproducts from the Production of Lithium Carbonate from Salt Lakes

Multiscale Investigation on the Performance of Engineered Cementitious Composites Incorporating PE Fiber and Limstone Calcined Clay Cement (LC3)

Early-age Performance and Mechanism of Magnesium Oxychloride Cement Mortar Mixed with Highland Barley Straw Ash

Synthesis and in vitro degradation of a novel magnesium oxychloride cement.

Mechanical Performance of MgO-doped Engineered Cementitious Composites (ECC)

Mechanical Strength and Water Resistance of Magnesium Oxysulfate Cement Based Lightweight Materials

Experimental Study on Mechanical Properties of a Novel Micro-Steel Fiber Reinforced Magnesium Phosphate Cement-Based Concrete

Direct Shear Study of Strengthening Layer Made of Continuous Carbon Fiber Fabric-Magnesium Oxychloride Cement Paste

Long-term Properties of Aeolian Sand-magnesium Oxychloride Cement Composites and Its Engineering Application

Feasibility Study of Smart Functional Strain-Hardening Cementitious Composites: Self-sensing Model and Experimental Performance

Experimental Study on the Properties and Shear Toughness of Strain-Hardening Cementitious Composite of the Combined Use of Polypropylene Fiber and Clinoptilolite