Abstract:In this study, a packed-bed dielectric barrier discharge reactor was built for the removal of biomass gasification tar. Two kinds of packing materials, glass pellets and a Ni/gamma-Al2O3 catalyst, were employed for the plasma-alone process and the plasma catalytic process, respectively. Toluene was used as the tar surrogate, and five typical gas combinations, N-2, N-2 + CO2, N-2 + CO2 + CO, N-2 + CO + H-2, and simulated gasification gas (SGG), were selected as carrier gases. The effects of the main components of the gasification gas on toluene removal under plasma and/or catalysis treatment were studied. The results indicated that the highest removal efficiency in the plasma-alone process was achieved in the N-2 atmosphere, and the addition of H-2, CO, or CO2 to N-2 led to a decrease in the removal performance. When Ni/gamma-Al2O3 was introduced into the plasma process, the best removal efficiency was obtained in the N-2 + CO2 atmosphere. However, the positive effect of CO2 on toluene removal switched to a negative effect when CO2 coexists with CO and H-2 in the gas mixture. In addition, both the terminating effect at low temperature and the occurrence of methanation induced by CO at high temperature could significantly inhibit the removal of toluene in the plasma catalytic process. Typically, in the SGG atmosphere, the highest toluene removal efficiencies under plasma-alone, catalysis-alone, and plasma catalysis treatments were 33.5, 38.6, and 92.5%, respectively. Furthermore, no CN-containing or O-containing compounds were identified as the major by-products in the plasma catalytic process, which is significantly different from what was observed in the plasma-alone process. Moreover, a detailed mechanism of toluene removal under plasma and plasma catalysis treatment was proposed after the analysis of gas and liquid products.

Plasma-Assisted Toluene Destruction in Simulated Producer Gas

Destruction of Toluene by Rotating Gliding Arc Discharge

Destruction of Toluene, Naphthalene and Phenanthrene As Model Tar Compounds in a Modified Rotating Gliding Arc Discharge Reactor

Gas Production from Polyethylene Terephthalate Using Rotating Arc Plasma

Removal of Dilute VOCs in Air by Post-Plasma Catalysis over Ag-based Composite Oxide Catalysts

Tar Removal from Biomass-Derived Fuel Gas by Pulsed Corona Discharges

Plasma Induced Toluene Decomposition on Alumina-Supported Mn-Based Composite Oxides Catalysts

Plasma Conversion of Toluene, Naphthalene, and Phenol as Model Tar Compounds in Simulated Synthetic Gas

Enhanced Reforming of Mixed Biomass Tar Model Compounds Using a Hybrid Gliding Arc Plasma Catalytic Process

Simultaneous Removal of Toluene, Naphthalene, and Phenol as Tar Surrogates in a Rotating Gliding Arc Discharge Reactor

Experimental and kinetic modeling study of tar partial oxidative reforming by dielectric barrier discharge plasma using toluene as a model compound

Hydropyrolysis of N-Hexane and Toluene to Acetylene in Rotating-Arc Plasma

Steam reforming of toluene as biomass tar model compound in a gliding arc discharge reactor

Plasma-Catalytical Removal of Tars from Fuel Gas Obtained by Biomass Gasification

VOCs degradation with non-thermal plasma and Ag-MnOx catalysis

Plasma reforming of tar model compound in a rotating gliding arc reactor: Understanding the effects of CO<sub>2</sub> and H<sub>2</sub>O addition

Steam Reforming of Toluene and Naphthalene As Tar Surrogate in a Gliding Arc Discharge Reactor.

Plasma-enabled Catalytic Steam Reforming of Toluene As a Biomass Tar Surrogate: Understanding the Synergistic Effect of Plasma Catalysis

Decomposition of gaseous toluene using a continuous flow discharge plasma reactor with new configurations

Byproducts and pathways of toluene destruction via plasma-catalysis

Mechanisms of Toluene Removal in Relation to the Main Components of Biosyngas in a Catalytic Nonthermal Plasma Process