Abstract:Tensile twinning is a main deformation mode in hexagonal close packed structure metals, so it is important to comprehensively understand twinning mechanisms which are not fully disclosed using 2D or small volume 3D characterization techniques. A large area 3D electron backscatter diffraction (EBSD) measurement and crystal plasticity modeling were carried out to investigate the tensile twinning behaviors in a magnesium (Mg) alloy. The results showed that tensile twinning activity was underestimated using conventional 2D EBSD scans. When compressed to yield point, the examined twin frequency with 2D was lower than that using 3D EBSD. The effects of Schmid factor (SF) on twinning were investigated. Almost all high Schmid factor (SF>0.35) grains were twinned. A surprising high twin frequency of 82% in middle SF (0.35>=SF>=0.15) grains was observed, which was unexpected since the middle SF grains were believed to be unfavorable for twinning. The twin frequency in low SF (SF<0.15) grains was slightly increased from 2D to 3D EBSD due to the small volume of twins. The shear stress maintained a high level and was homogeneously distributed in high SF grains, facilitating twin nucleation and growth. The shear stress was distributed heterogeneously within the middle SF grains, and twins were nucleated within areas with positive shear stress. The shear stress in low SF grains was not favorable for twinning and twins occurred in the vicinity of stress accumulation. Twinning activities in the same grain varied on different layers. It was attributed to the stress fluctuation derived from grain environment changes.

Simultaneous Multiscale Measurements on Dynamic Deformation of a Magnesium Alloy with Synchrotron X-Ray Imaging and Diffraction

Multiscale Measurements on Temperature-Dependent Deformation of A Textured Magnesium Alloy with Synchrotron X-Ray Imaging and Diffraction

Anisotropic Deformation of Extruded Magnesium Alloy AZ31 under Uniaxial Compression: A Study with Simultaneous in Situ Synchrotron X-Ray Imaging and Diffraction

Effect of Pre-Existing Twinning on Strain Localization During Deformation of a Magnesium Alloy

Dynamic plasticity of AZ31 magnesium alloy: Experimental investigation and constitutive modeling

In Situ Monitoring of Dislocation, Twinning, and Detwinning Modes in an Extruded Magnesium Alloy under Cyclic Loading Conditions

Dynamic Deformation Behavior of As-Extruded Mg-Gd-Y Magnesium Alloy and the Microstructural Evolution

Characterizing microscale deformation mechanisms and macroscopic tensile properties of a high strength magnesium rare-earth alloy: A combined experimental and crystal plasticity approach

Electron Backscatter Diffraction Observations of Twinning–detwinning Evolution in a Magnesium Alloy Subjected to Large Strain Amplitude Cyclic Loading

Anisotropy and Deformation Mechanisms ofAs-Extruded Mg-3Zn-1Y Magnesium AlloyUnder High Strain Rates

Investigation of Grain Subdivision at Very Low Plastic Strains in A Magnesium Alloy

Dynamic tensile properties and microstructural evolution of extruded EW75 magnesium alloy at high strain rates

Dynamic testing at high strain rates of an ultrafine-grained magnesium alloy processed by ECAP

Multiscale in-situ characterization of static recrystallization using dark-field X-ray microscopy and high-resolution X-ray diffraction

In-situ synchrotron X-ray tomography investigation of damage mechanism of an extruded magnesium alloy in uniaxial low-cycle fatigue with ratchetting

Transmission Electron Microscope In Situ Straining Technique to Directly Observe Defects and Interfaces During Deformation in Magnesium

Three-dimensional study of grain scale tensile twinning activity in magnesium: A combination of microstructure characterization and mechanical modeling

Deformation Mechanisms and High Strain Rate Properties of Magnesium (mg) and Mg Alloys

Deformation behavior and microstructure evolution of an AM80 magnesium alloy at large strain rate range

Capture Deformation Twinning in Mg During Shock Compression with Ultrafast Synchrotron X-Ray Diffraction.

Room-Temperature Microstructural Evolution of Extruded AM80 Magnesium Alloys under Dynamic Loading