Abstract:This study investigated the axial two-phase flow evolution and interfacial area transport characteristics downstream of the mixing vane spacer grid (MVSG) in a tight lattice rod bundle channel with a subchannel hydraulic diameter of D h = 17.27 mm. The experiment was conducted under the air-water two-phase flow at room temperature and atmospheric pressure. The phase distributions of 6 positions downstream of MVSG ( Z / D h = 9.15, 14.94, 20.73, 26.52, 32.31, and 61.26) were measured utilizing a self-developed double-layer wire-mesh sensor (WMS). 42 cases were obtained, involving the bubbly flow, cap-bubbly flow, and slug flow. Void fraction, bubble velocity, interfacial area concentration (IAC), and bubble size distribution (BSD) databases were built. Under the group-1 (G-1) flow, due to the swirling flow generated by MVSG, the G-1 bubbles were drawn from the bundle surface and the gap region into the subchannel center to form a spindle core-peak distribution. BSD results demonstrate that the swirling flow promotes bubbles' coalescence. The one-dimensional (1-D) void fraction and IAC downstream of the MVSG decrease first and then recover, which contrasts with the non-mixing vane spacer grid (N-MVSG) effect. It was attributed to the increment of the bubbles' velocity after MVSG due to the bubbles' migration to the channel center and coalescence. Under the group-2 (G-2) flow, MVSG intensifies the core peak distribution of void fraction, and the void fraction profile is also spindle-shaped. The obvious bubbles' break-up occurs at Z / D h = 14.94 attributed to the swirling decay. The 1-D void fraction and IAC transport indicate, that with the liquid-velocity increment, the MVSG effect is different from the N-MVSG effect, which is mainly achieved by affecting the G-1 bubbles' dynamic behaviors. The model evaluation utilizing the interfacial area transport equation (IATE) closing bubble interaction source/sink terms indicates that the advection effect dominates the IAC evolution and the contribution of the pressure effect is weak. The remarkable bubbles' coalescence occurs under the high liquid velocity. In future studies, the additional bubble break-up and coalescence source/sink term model considering the MVSG effect should be developed based on these cases to improve the IATE prediction ability.

Experimental Study on Interfacial Area Transport of Two-Phase Flow under Vibration Conditions

Investigation of Vibration Amplitude Effect on Local Flow Parameters of Two Phase Flow

Experimental study of vibration effects on local interfacial parameters in boiling flow

Experiment investigation on two phase flow parameter distribution in annular channel under vibration condition

Study of Wave-Induced Mass Transport and Internal Mixing Based on a Two-Liquid VOF Model

Bubble Characterization in the Gas-Solid Fluidized Bed Using an Intrusive Acoustic Emission Sensor Array

Numerical Simulation for Vibration of Interferometric Probein Wet Steam Flow Field

Void Fraction Measurement Of Gas-Liquid Two-Phase Flow Based On (Cd)-D-4 Technique

Experimental and Numerical Investigations of Film Flow Behaviors in Resonance Section over Corrugated Plates

Vibration Effects On Bubbly Flow Structure In An Annulus

Investigation on two-phase distribution in a vibrating annulus

Experimental study of two-phase flow structure in churn-turbulent to annular flows

Simulation On Flow Field Induced By Vibration Surface Of Low Frequency

Investigation of Oil-Air Two-Phase Mass Flow Rate Measurement Using Venturi and Void Fraction Sensor

Local Measurement of Bubbly Flow in Helically Coiled Tubes Using Double-Sensor Conductivity Probe

Local Void Fractions and Bubble Velocity in Vertical Air-Water Two-Phase Flows Measured by Needle-Contact Capacitance Probe

Relationship between fluctuating differential pressure and void fraction of gas-liquid two-phase flow in Venturi tube

Ultrasonic oscillatory two-phase flow in microchannels

Two-phase flow evolution and interfacial area transport downstream of the mixing-vane spacer grid in rod bundle channels

Experimental Investigation of Flow-Induced Vibration in Gas/Shear-Thinning Liquid Flows in Vertical Pipe

Investigation on Gas-Liquid Two-Phase Flow-Induced Vibrations of a Horizontal Elastic Pipe