Abstract:<p>The local phase distribution of adiabatic air-water two-phase flow in churn-turbulent to annular flows was experimentally investigated using the Two-Sensor Droplet-Capable Conductivity Probe. The experiments were performed in a 2.54 cm inner diameter vertical round pipe at downward flows. Twelve flow conditions in churn-turbulent to annular flows were chosen for the current study. The inlet superficial gas velocity ranged from 5.68 m/s to 17.19 m/s, and the inlet superficial liquid velocity ranged from 1.21 m/s to 2.64 m/s. The DCCP-2 is able to distinguish droplets, liquid ligaments, bubbles, and continuous gas. The radial profiles of volume fraction, frequency, axial interfacial velocity, and chord length of droplets, ligaments and bubbles were measured. The experimental results showed that gas volume fraction had a center-peak distribution, and the maximum gas volume fraction in centerline could exceed 95%. The volume fraction of droplets was very low, only on the order of 0.1 %. Droplet concentration also showed a center-peak distribution. Both ligament and bubble volume fraction showed a near-wall peak distribution. The ligament volume fraction in the near wall region could reach 80%, which indicated the existence of a film region near the wall and likely includes surface waves on the film. The volume fraction profile of gas, droplets, ligaments, and bubbles showed the tomography structure in churn-turbulent to annular flows. The effects of flow conditions on phase distribution were also studied. An interesting feature was that both the increase of gas flux and the increase of liquid flux tended to increase the bubble volume fraction. The statistical distribution of droplet size was found to be invariant of radial position. The droplet velocity at centerline was generally larger than the superficial gas velocity, which can be attributed to the gravitational effects at downward flows.</p>

Experimental and Numerical Investigations of Film Flow Behaviors in Resonance Section over Corrugated Plates

Experimental and Numerical Investigation on Gravity-Driven Film Flow over Triangular Corrugations

Flow Characteristics of Film Flow over 3D Corrugations Column Plate

Comparative Study on the Characteristics of Film Flow with Different Corrugation Plates

Hydrodynamics of New Structured Packings: an Experimental and Micro-scale CFD Study

Numerical Simulation of Viscous Flow Past an Oscillating Square Cylinder Using A Cip-Based Model

Study of Wave-Induced Mass Transport and Internal Mixing Based on a Two-Liquid VOF Model

Direct numerical simulation of deformable rising bubbles at low Reynolds numbers

Examination of Appropriate Formulations for Velocity and Pressure Calculation Methods at Interfacial Region on Collocated Physical Variables' Distribution

Three-Dimensional Numerical Simulation of Air Exhausted from Submerged Nozzles

Numerical simulation of flow around a transversely oscillating square cylinder at Re =22000

Evolution of turbulent liquid films on the corrugated plate—rivulets and slender water columns necking rupture

Effect of structural parameters of corrugated plate on the evolution of solitary waves and liquid film thickness distribution

Experimental study of two-phase flow structure in churn-turbulent to annular flows

Numerical simulation of gas-liquid two-phase flow impacting fixed structure by CLSVOF/IB method based on OpenFOAM

Simulation-based Study of Low-Reynolds-number Flow Around a Ventilated Cavity

Numerical investigation of gas-liquid flow hydrodynamics in three-dimensional bottom-blown reactor via LES-VOF coupled model

Experimental Study on the Characteristics of Liquid Layer and Disturbance Waves in Horizontal Annular Flow

Fully nonlinear numerical investigations on the dynamics of fluid resonance between multiple bodies in close proximity

Numerical Study of the Surfactant-Covered Falling Film Flowing Down a Flexible Wall

Experimental investigation on the multiphase flow characteristics of oblique water entry of semi-closed cylinder