Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

Evaporation and crystallization of a droplet of desulfurization wastewater from a coal-fired power plant

Evaporation Characteristics of a Single Desulfurization Wastewater Droplet in High-temperature Gas

Experimental study on the treatment of desulfurization wastewater from coal-fired power plant by spray evaporation

Evaporation and Concentration of Desulfurization Wastewater with Waste Heat from Coal-Fired Power Plants

Study on Spray Evaporation Treatment of Desulfurization Wastewater

Occurrence states and migration of water during the evaporation of desulfurization wastewater

Numerical Investigation on the Evaporation Performance of Desulfurization Wastewater in a Spray Drying Tower without Deflectors

Study on the evaporation performance of concentrated desulfurization wastewater and its products analysis

Experimental Study on the Evaporation and Chlorine Migration of Desulfurization Wastewater in Flue Gas

Process simulation on atomization and evaporation of desulfurization wastewater and its application

Analysis of Main Influencing Factors of the Wastewater Evaporation in Flue Duct

Spray drying of desulfurization wastewater: Drying characteristics, product analysis and potential risk assessment

Chloride release characteristics of desulfurization wastewater droplet during evaporation process using the single droplet drying method

Migration and Agglomeration of Chlorine in Dechlorination of Coal-Fired Flue Gas

Thermodynamic properties of evaporative crystallization of high-salt wastewater

Solid-liquid phase equilibrium relationship of high salt wastewater of coal chemical industry and mechanism of crystallization and scaling process

Promoting fine particle removal in double-tower cascade wet flue gas desulfurization system by flue gas temperature reduction

Simulation Study on Centrifugal Spray Evaporation Characteristics and Process Optimization of Desulfurization Wastewater

Droplet Evaporation to Boiling in Van Der Waals Fluid

Application and performance evaluation of desulfurization wastewater spray drying technology

Experimental Study on Emission Characteristics of Particulate Matters from Wet Flue Gas Desulfurization System of a Coal-fired Power Plant