Abstract:Non-equilibrium molecular dynamics simulations (NEMD) are carried out to study the evaporation behaviors of high-salinity wastewater droplets in a high-temperature environment (>500 K). Detailed information on interfacial properties and evaporation characteristics of wastewater droplets containing multiple salts are monitored quantitatively for the first time. To investigate how ions and molecules interact with each other during evaporation, nucleation and growth of ions clusters and the dehydration process are studied by the coordination number analysis. The accuracy of the model is validated by the experimental results, and then effects of ambient temperatures, compositions, and initial sizes are considered. The results show that when the evaporation reaches the steady state in the 600 K ambience, the droplet evaporation rate of wastewater is much smaller than that of the pure water, which can be seen from the evaporation constant (5.58 × 10 −9 m 2 /s for pure water vs 4.60 × 10 −9 m 2 /s for wastewater). After this steady state, the evaporation rate for wastewater is reduced, during which nucleation of ion pairs and dehydration would occur. Ion-water interaction, smaller temperature difference between ambience and droplets, and higher sphericity contribute to the decline in the evaporation rate of wastewater. Nucleation trends of different ion pairs in wastewater vary significantly, and divalent cations (Mg 2+ and Ca 2+ ) play an important role in restricting the motions of water molecules and forming clusters, as shown in the higher average counter ion coordination number. Dehydration of the ions will not occur until most water molecules are evaporated, which is more difficult for divalent ions. Increasing thermostat temperature, decreasing total dissolved solids and decreasing initial sizes are conducive to accelerating the overall evaporation and nucleation rate. The research gives a better understanding of the microscopic mechanisms of wastewater droplet evaporation and further aids in the design and optimization of the thermal desalination process.

Thermodynamic properties of evaporative crystallization of high-salt wastewater

Molecular dynamics study on evaporation of high-salinity wastewater droplet

Solid-liquid phase equilibrium relationship of high salt wastewater of coal chemical industry and mechanism of crystallization and scaling process

Evaporation process for treating high-salinity industrial wastewater at low temperatures and ambient pressure

Highly efficient freezing desalination technology: Parameters optimization and model configuration

Crystallization techniques in wastewater treatment: An overview of applications

Simulation and Experimental Study of Circulatory Flash Evaporation System for High-Salt Wastewater Treatment

Influence of Organic Impurities on Fractional Crystallization of NaCl and Na2SO4 from High-Salinity Coal Chemical Wastewater: Thermodynamics and Nucleation Kinetics Analysis

A Salt-Rejecting Solar Evaporator for Continuous Steam Generation

Evolution of Morphology and Distribution of Salt Crystals on a Photothermal Layer During Solar Interfacial Evaporation.

Research on atomization evaporation characteristics and parameter optimization of a novel spray evaporation desalting system

Study on the effect of volatile organic compounds on the treatment of high-salt wastewater by low-temperature evaporation

Scaling trend of coal chemical saline wastewater in falling film evaporator: experimental solid-liquid equilibrium and numerical simulation

Highly efficient and salt rejecting solar evaporation via a wick-free confined water layer

Development of an Evaporation Crystallizer for Desalination of Alkaline Organic Wastewater Before Incineration

Heat Transfer Study from a Salty Droplet Film on a Horizontal Tube in Mechanical Vapor Recompression Crystallization System

Characteristics, mechanisms and measurement methods of dissolution and deposition of inorganic salts in sub-/supercritical water

Evaporation Characteristics of a Single Desulfurization Wastewater Droplet in High-temperature Gas

Application of the electrical localized heating method in direct contact Membrane Distillation Crystallization process

Experimental and numerical investigation on evaporation characteristics of high salinity wastewater by rotary spray

Extendable Solar Interfacial Evaporator with High Salt Resistance Achieved by Managing the Evaporation Region