Abstract:To accommodate the integration of renewable energy, coal-fired power plants must take on the task of peak regulation, making the low-load operation of boilers increasingly routine. Under low-load conditions, the phase transition point (PTP) of the working fluid fluctuates, leading to potential flow instability, which can compromise boiler safety. In this paper, a one-dimensional coupled dynamic model of the combustion and hydrodynamics of a supercritical boiler is developed on the Modelica/Dymola 2022 platform. The spatial distribution of key thermal parameters in the furnace and the PTP position in the water-cooled wall (WCW) are analyzed in a 660 MW supercritical boiler when parameters on the combustion side change under full-load and low-load conditions. The dynamic response characteristics of the temperature, mass flow rate, and the PTP position are investigated. The results show that the over-fire air (OFA) ratio significantly influences the flue gas temperature distribution. A lower OFA ratio increases the flue gas temperature in the burner zone but reduces it at the furnace exit. The lower OFA ratio leads to a higher fluid temperature and shortens the length of the evaporation section. The temperature difference in the WCW outlet fluid between the 20% and 60% OFA ratios is 11.7 °C under BMCR conditions and 7.4 °C under 50% THA conditions. Under the BMCR and 50% THA conditions, a 5% increase in the coal caloric value raises the flue gas outlet temperature by 32.7 °C and 35.4 °C and the fluid outlet temperature by 6.5 °C and 9.9 °C, respectively. An increase in the coal calorific value reduces the length of the evaporation section. The changes in the length of the evaporation section are −2.95 m, 2.95 m, −2.62 m, and 0.54 m when the coal feeding rate, feedwater flow rate, feedwater temperature, and air supply rate are increased by 5%, respectively.

Coupled simulation of the combustion and fluid heating of a 300 MW supercritical CO2 boiler

Study on coal combustion characteristics in a 350MW supercritical tangentially boiler

Coupled Modeling of Combustion and Heat Transfer Process of a Supercritical CO2 Boiler

Numerical investigation on oxy-combustion characteristics of a 200MW e tangentially fired boiler

Simulation on Coal-Fired Supercritical CO2 Circulating Fluidized Bed Boiler: Coupled Combustion with Heat Transfer

Coupled Simulation and Deep-Learning Prediction of Combustion and Heat Transfer Processes in Supercritical CO2 CFB Boiler

Simulation of Gas-Solid Combustion Characteristics in a 1000 MW CFB Boiler for Supercritical CO2 Cycle

Coupled Modeling of Combustion and Hydrodynamics for a Coal-Fired Supercritical Boiler

Numerical analysis and modified thermodynamic calculation methods for the furnace in the 1000 MW supercritical CO2 coal-fired boiler

Design and Performance Analysis of Coal-Fired Fluidized Bed for Supercritical CO2 Power Cycle

Simulation of Dynamic Characteristics of Supercritical Boiler Based on Coupling Model of Combustion and Hydrodynamics

Numerical Investigation of Heat Transfer Characteristics of Supercritical CO2 Tube in Combustion Chamber of Coal-Fired Boiler

Gas-Solid Hydrodynamics and Combustion Characteristics in a 600 MW Annular CFB Boiler for Supercritical CO<sub>2</sub> Cycles

Experimental Test, Numerical Analysis and Thermal Calculation Modeling of Hundreds Kwth-Class Supercritical CO2 Fossil-Fired Boiler System

Numerical Simulation of O2／CO2 Recycled Flue Gas Combustion in a 300 MW Boiler

Experimental test, numerical analysis and thermal calculation modeling of hundreds kW th -class supercritical CO 2 fossil-fired boiler system

Numerical Simulation of Flow and Heat Transfer Between Supercritical CO2 Tube and Flue Gas

Numerical Simulation of Combustion Processes in an Ultra Supercritical Boiler

Numerical Study on Combustion and Heat Transfer Properties under Oxy-fuel Condition in a 600MW Utility Boiler

The comprehensive solution to decrease cooling wall temperatures of sCO2 boiler for coal fired power plant

Numerical Study on the Effect of Separated Over-Fire Air Ratio on Combustion Characteristics and NOx Emission in a 1000 MW Supercritical CO2 Boiler