Abstract:Superheated droplets vaporized in a vacuum or vapor chamber was studied using smoothed particle hydrodynamics method.The two-phase fluids of vapor and liquid with a diffused interface were modeled by Navier-Stokes-Korteweg equations,with the van der Waals equation of state.The liquid-vapor separation was processed with different initial temperature and density.Simulation was firstly validated by the proper equilibrium states with analytical data from the binodal line of Maxwell construction,as well as the droplet surface tension compared with experimental and other groups'numerical data in a good agreement.Droplet morphology,density,temperature and entropy increment were then carefully examined during the dynamic process from evaporation to boiling.Four phase transitions patterns were concluded,namely from surface evaporation,internal bubble,fragment and explosion,to flash boiling with increasing equivalent superheat degree that is defined by the non-dimensional superheat temperature over surface tension.Results showed that droplet temperature and density decreased slightly at surface evaporation when equivalent superheat degree was lower than 1/3.Above this criterion,the internal bubble could be sustained.Growth of new liquid nucleates and connected secondary liquid ring were calculated by domain growth theory.We found that droplet continuous to expand at high superheat but withdrawn at equivalent superheat degree equal to or lower than 0.52.At equivalent superheat degree higher than 1,the growth and expansion of droplet resulted in liquid fragment and explosion to many small secondary droplets.Mean mass and diameter of these droplets were found to have power-law dependency on the expansion rate.Finally,fast flash boiling occurred at equivalent superheat degree higher than 3.The vapor pressure in the chamber showed a negative linear correlation between the overpressure and the atmospheric pressure.We also found out that comparing to increase the pressure value,dense gas had better efficiency on retarding the propagation of shock wave.

A New Flash Boiling Model for Single Droplet

CFD Simulations and Experimental Verification on Nucleate Pool Boiling of Liquid Nitrogen

Droplet Evaporation to Boiling in Van Der Waals Fluid

Investigation of Bubble Interaction in a Temporal and Spatial Heat Flux Partitioning Model for Subcooled Flow Boiling

Quantitative Observation on Characteristics and Breakup of Single Superheated Droplet

Modeling Droplet Vaporization and Combustion with the Volume of Fluid Method at a Small Reynolds Number

On Understanding the Transition from Internal to External Flash Boiling

Mathematical Modeling of Flash Boiling Phenomena in Superheated Sprays at low Degree of Superheat using Dirichlet Hyperboloids

A Unifying Bubble-Layer-Based Theoretical Model for Flow Boiling and Application to a Rod Bundle

Numerical Analyses of Flashing Jet Structure and Droplet Size Characteristics

Vaporization dynamics of a super-heated water-in-oil droplet: modeling and numerical solution

A BUBBLE-LAYER-BASED MECHANISTIC MODEL FOR THE SLIGHTLY SUBCOOLED FLOW BOILING IN VERTICAL TUBES

Droplet boiling on heated surfaces with various wettabilities

CFD-Based Numerical Simulation of Water Film Flash Evaporation with a New Flash Evaporation Model

Investigation on cavitation enhancement on flash boiling atomization using two-dimensional slit nozzles

Microscopic and Macroscopic Characterization of Spray Impingement under Flash Boiling Conditions with the Application of Split Injection Strategy

Impact and boiling characteristics of a droplet on heated surfaces: A 3D lattice Boltzmann study

A Coupled Vaporization Model Based on Temperature/species Gradients for Detailed Numerical Simulations Using Conservative Level Set Method

An exploration on collapse mechanism of multi-jet flash-boiling sprays

Evolution and heat transfer after droplet impact on heated liquid film with vapor bubbles inside

Internal Boiling and Superheating in Vaporizing Multicomponent Droplets