Abstract:Objective: One potential nonstandard seating configuration for vehicles with automated driving systems (ADS) is a reclined seat that is rear-facing when in a frontal collision. There are limited biomechanical response and injury data for this seating configuration during high-speed collisions. The main objective of this study was to investigate thoracic biomechanical responses and injuries to male postmortem human subjects (PMHS) in a rear-facing scenario with varying boundary conditions.Method: Fourteen rear-facing male PMHS tests (10 previously published and 4 newly tested) were conducted at two different recline angles (25-degree and 45-degree) in 56 km/h frontal impacts. PMHS were seated in two different seats; one used a Fixed D-Ring (FDR) seat belt assembly and one used an All Belts To Seat (ABTS) restraint. For thoracic instrumentation, strain gages were attached to ribs to quantify strain and fracture timing. A chestband was installed at the mid-sternum level to quantify anterior-posterior (AP) chest deflections. Data from the thorax instrumentation were analyzed to investigate injury mechanisms.Results: The PMHS sustained a greater number of rib fractures (NRF) in the 45-degree recline condition (12 ± 7 NRF for ABTS45 and 25 ± 18 NRF for FDR45) than the 25-degree condition (6 ± 4 NRF for ABTS25 and 12 ± 8 NRF for FDR25), despite AP chest compressions in the 45-degree condition (-23.7 ± 9.4 mm for ABTS45 and -39.6 ± 11.9 mm for FDR45) being smaller than the 25-degree condition (-38.9 ± 16.9 mm for ABTS25 and -55.0 ± 4.4 mm for FDR25). The rib fractures from the ABTS condition were not as symmetric as the FDR condition in the 25-degree recline angle due to a belt retractor structure located at one side of the seatback frame. Average peak AP chest compression occurred at 45.7 ± 3.4 ms for ABTS45, 45.6 ± 3.1 ms for FDR45, 46.7 ± 1.9 ms for ABTS25, and 46.9 ± 2.3 ms for FDR25. Average peak seatback resultant force occurred at 43.9 ± 0.9 ms for ABTS45, 44.6 ± 0.8 ms for FDR45, 42.5 ± 0.2 ms for ABTS25, and 41.5 ± 0.5 ms for FDR25. The majority of rib fractures occurred after peak AP chest compression and peak seatback resultant force likely due to the ramping motion of the PMHS, which might create a combined loading (e.g., AP deflection and upward deflection) to the thorax. Although NRF in the 45-degree reclined condition was greater than the 25-degree recline condition, similar magnitudes of rib strains were observed regardless of seat and restraint types, while strain modes varied.Conclusions: The majority of rib fractures occurred after peak AP chest compression and peak seatback force, especially in FDR25, ABTS45, and FDR45, while the PMHS ramped up along the seatback. AP chest compression, seatback load, and strain measured along the rib could not explain the greater NRF in the 45-degree recline conditions. A complex combination of AP chest deflection with upward deflection was discovered as a possible mechanism for rib fractures in PMHS subjected to rear-facing frontal impacts in this study.

AIS 3+ Thoracic Injuries Among Drivers in Real-World Motor Vehicle Frontal Crashes: The Effect of Impact Direction, Impact Location and Status of Seat Belt

The Combined Effects of Impact Direction and Impact Location on Serious-to-Maximum Injuries among Drivers in Motor Vehicle Frontal Crashes

Impact direction effect on serious-to-fatal injuries among drivers in near-side collisions according to impact location: focus on thoracic injuries.

The effect of seatbelt pre-tensioners and load limiters in the reduction of MAIS 2+, MAIS 3+, and fatal injuries in real-world frontal crashes

Effectiveness of Booster Seats Compared with No Restraint or Seat Belt Alone for Crash Injury Prevention

Driver injury in near- and far-side impacts: Update on the effect of front passenger belt use

The Influence of Impact Speed on Chest Injury Outcome in Whole Body Frontal Sled Impacts

Risk of thoracic injury from direct steering wheel impact in frontal crashes

Influence of Vehicle Model Year and Occupant Seating Position on Serious Injury Risk in Near-Side Collision

The Effects of Inboard Shoulder Belt and Lap Belt Loadings on Chest Deflection

Thoracic responses and injuries to male postmortem human subjects (PMHS) in rear-facing seat configurations in high-speed frontal impacts

Study of AEB and active seat belt on driver injury in vehicle-vehicle frontal oblique crash

Age Effects on Injury Pattern of Rear-Seat Child Occupants in Frontal Crashes

Motor Vehicle Restraint System Use and Risk of Spine Injury

Mechanisms of chest injuries from steering wheel intrusion in frontal collisions

Optimization of the Driver’s Seat Belt and Injury Biomechanical Analysis in Real-World Minivan Small Offset Impact Accident Scenarios

Severe injury in multiple impacts: Analysis of 1997-2015 NASS-CDS

Effects of an integrated safety system for swivel seat arrangements in frontal crash

Biomechanical response and injury effects on occupant's thorax–abdomen under seat belt loading

A Simulation Study on the Efficacy of Advanced Belt Restraints to Mitigate the Effects of Obesity for Rear-Seat Occupant Protection in Frontal Crashes

Cross-correlation between the controlled collision environment and real-world motor vehicle collisions: Evaluating the protection of the thoracic side airbag