Abstract:A series of novel Ti(IV) complexes bearing new type of nonsymmetric amine-bis(phenolate) tetradentate ligands, Me2NCH2CH2N[2-O-3-R-1-5- t BuC6H2] [CH2(2-O-3-R-2-5- t BuC6H2)]TiCl2 [R-1 = R-2 = Bu-t (1); R-1 = R-2 = CPhMe2 (2); R-1 = R-2 = CPh2Me (3); R-1 = CPh3, R-2 = Bu-t (4); R-1 = CPh3, R-2 = CPhMe2 (5); R-1 = CPh3, R-2 = CPh2Me (6); and R-1 = R-2 = CPh3 (7)], have been synthesized and characterized by H-1 and C-13 NMR. The X-ray crystallography analysis on complexes 5 and 6 demonstrates that both complexes exhibit a distorted octahedral geometry around their central metals. When activated with methylaluminoxane (MAO), dry-MAO, MAO/2,6-Ditert-butyl-4-methylphenol (BHT), or Al-i Bu-3/CPh3B(C6F5)(4), these new complexes display moderate to high catalytic activities for ethylene polymerization and produce ultrahigh molecular weight polyethylenes (up to 3.74 x 10(6) g mol(-1)). Polymers with low to moderate isotacticity are formed from the polymerization reactions of propylene or 1-hexane, and the isotacticity of the produced polymers increases with the increase in bulkiness of the ligands of the titanium complexes. For copolymerization reactions of ethylene/1-hexene or ethylene/1-octene, the MAO/BHT or dry-MAO activated catalytic systems show relatively high catalytic activities [106-107 g of polymer (mol T-i)(-1) h(-1)] and produce polyolefin thermoplastic elastomer (POE) or linear low-density polyethylene with high to ultrahigh molecular weights (10(5)-10(6) g of mol(-1)) and moderate to high comonomer incorporations. The mechanical properties for some typical UHMWPE and POE samples were also determined and the results are in line with expectations. In most cases, these new titanium complexes display notable high thermal stability and long lifetime for the examined olefin polymerization reactions.

Synthesis of atactic polypropylene elastomers with half-titanocene catalyst in different solvents

Ethylene polymerization by diphenyl ether bridged dinuclear titanocenes/MAO

Synthesis of Ultrahigh-Molecular-weight Ethylene-1-hexene Copolymers with High Hexene Content Via Living Polymerization with Fluorinated Bis(phenoxy-Imine) Titanium(iv).

Synthesis and characterization of titanium(IV) complexes bearing end functionalized biphenyl: Efficient catalysts for synthesizing high molecular weight polyethylene

Development of a Catalytic System for Synthesis of High Molecular Weight Polypropylene Elastomers

Amorphous Elastomeric Ultra-High Molar Mass Polypropylene in High Yield by Half-Titanocene Catalysts

Propylene Polymerization to High Molecular Weight Atactic Polypropylene and Copolymerization with 1-Hexene Using Monocyclopentadienyl Titanium Catalysts.

Synthesis of High-Molecular-Weight Polypropylene Elastomer by Propylene Polymerization Using α-Diimine Nickel Catalysts

Influence of Cocatalyst on High Temperature Polymerization of Propylene Catalyzed by Ziegler-Natta Catalyst

Microtacticity of Polypropylene Fractions Produced by Different Active Sites of Heterogeneous Ziegler-Natta Catalyst

High temperature polymerization of propylene catalyzed by MgCl2-supported Ziegler–Natta catalyst with various cocatalysts

Studies on Synthesis of Low Isotactic Polypropylene by Using a Novel MgCl2-supported and Low Ti-loading Catalyst

Investigation on Terpolymer of Ethylene/propylene/ω-Bromo-α-olefins Catalyzed by Titanium Complexes

Epoxidation of Propylene with Dilute H 2 O 2 over Titanium Silicalite Containing Trace Aluminum

Synthesis of Ultrahigh Molecular Weight Ethylene-Based (co)polymers with Titanium Complexes Bearing Nonsymmetric Amine-bis(phenolate) Ligands

Synthesis and performance of olefin copolymers produced with monocyclopentadienyl titanium phosphinimide complex as viscosity modifiers

Synthesis of Aps-B-P(S-Co-E)-B-Pe Block Copolymers Catalyzed with Half-Titanocene/Zn/Bdge/Mao Catalyst System

Fluorinated Bis(phenoxyketimine)titanium Complexes for the Living, Isoselective Polymerization of Propylene: Multiblock Isotactic Polypropylene Copolymers Via Sequential Monomer Addition.

Oscillating stereocontrol: a strategy for the synthesis of thermoplastic elastomeric polypropylene

Half-titanocence anilide complexes Cp′TiCl2[N(2,6-R 1 2C6H3)R2]: Synthesis, structures and catalytic properties for ethylene polymerization and copolymerization with 1-hexene

Half-titanocenes catalysts containing phosphine nitrogen ligands for ethylene and ethylene-propylene polymerization