Abstract:Because traditional three-way catalysts(TWC) can't reduce NOx efficiently in excess oxygen,researchers have paid more attention to lean NOx removal at home and abroad,and plasma enhanced selective catalytic reduction(plasma-SCR) was considered as a promising way to achieve NOx control.In this paper,the two-stage plasma-enhanced SCR system,which meant that plasma reator was separated from catalytic reactor,was selected,and the relationships between plasma discharge voltage,frequency,GHSV and NOx removal rate,the selectity of NO to NO2 were studied carefully.The experimental apparatus included gas control system,ac power source with high frequency,dielectric barrier discharge(DBD) reactor,catalytic reactor and analysis instruments. NO,O2 and N2 were simulated the exhaust gas,and C2H4 was added into the manifold as reductant.InZSM-5 containing 3%In(wt) was prepared as catalyst.Plasma only,catalysis only and plasma enhanced SCR were conducted respectively to compare the removal rate of NOx.The results showed that plasma could oxidate NO into NO2 efficiently,and most of NOx was converted into other N-containing compounds instead of N2 under higher plasma voltage when plasma alone.These N-containing products would be oxidated or reducted to NOx again over catalyst.After plasma proceeded,HCHO,CH3NO3,CO and other intermediates were produced,which would greatly influence the performance of NOx removal in catalysis stage.Plasma could effectively improve NOx removal rate when combined with SCR,which relied on plasma voltage significantly.At the same time,the effects of GHSV in catalytic stage and frequency of power supply were both investigated in the experiments.It was found that lower GHSV benefited for NOx removal,while the frequency didn't represent prominent influence in the range from 2.5kHz to 4kHz.

PROGRESS IN REMOVAL OF NOx FROM DIESEL ENGINE EXHAUST GAS BY NON-THERMAL PLASMA

Non-thermal lasma assisted incineration of particulate matter

Fundamentals and Environmental Applications of Non-thermal Plasmas: Multi-pollutants Emission Control from Coal-Fired Flue Gas

Role of Nitrogen-Containing Organic Compound in Plasma Exhaust Treatment

Research advance in non-thermal plasma induced selective catalytic reduction NO_x with low hydrocarbon compounds

Research on Lean NO_x Removal by Plasma Enhanced Selective Catalytic Reduction over InZSM-5

Removing NOx Emission from Diesel Engine with Plasma-assisted NH3-SCR

Experimental Study of Non-Thermal Plasma on Simulated Diesel Emissions

A Novel Four-Way Plasma-Catalytic Approach for the after Treatment of Diesel Engine Exhausts

Removal of NOx with Selective Catalytic Reduction Based on Nonthermal Plasma Preoxidation

NOx removal by non-thermal plasma reduction: experimental and theoretical investigations

Plasma technology to remove NOx from off-gases

An investigation of the treatment of particulate matter from gasoline engine exhaust using non-thermal plasma

Optimization for Plasma-facilitated Catalytic Reduction of NO_x

Nitrogen oxide removal by non-thermal plasma for marine diesel engines

Experimental Study of Non-thermal Plasma Injection System Converting NOx in Simulated Diesel Emissions

New Experiment of Diesel Exhaust Treatment by Atmospheric Pressure Plasma–Wood Fiber Combination

An Analysis of Exhaust Emission of the Internal Combustion Engine Treated by the Non-Thermal Plasma

Effect Of Plasma On The Hybrid Plasma-Catalytic Removal Of Hydrocarbons, Nitrogen Oxides And Diesel Soot

Purification method for removing nitrogen oxides in stationary source tail-gas using low-temperature plasma

Nonthermal plasma removal of CH4-NOx under LNG engine exhaust environment: Experiment, mechanism and kinetic analysis