Abstract:Fly ashes,obtained from three commercial CFB boilers with burning Fujian anthracites,were studied in this paper.By using standard dry-sieving techniques and LOI method,the size distributions of fly ashes and the carbon contents of different size fractions were measured.With the help of SEM and EDX technique,the particle superficial property of fly ash was examined and divided into carbon(soot,or graphite),char,and slag.The residual carbon was enriched from fly ash by the floating-separation technique,and its reactivity was then measured via a non-isothermal TGA experiment.The results was compared with that of its corresponding parent coal.Furthermore,in a laboratory pilot scale fluidized bed furnace,the source of the unburned carbon in the fly ash was explored.It is shown that for CFB boilers using a single cyclone separator,the largest amount of fly ash particles lies in the particle size range from 0.0385mm to 0.0500mm,and so does the unburned carbon fraction;and for CFB boiler equipped with two separators,the largest amount of fly ash particles and unburned carbon fraction lies in a particle size range of 0.0500mm~0.0750mm.There are three kinds of particles existing in fly ashes,which are granular unburned carbon,flocculent slag and char.The reactivity of the unburned carbon in fly ashes is relatively higher than that of its parent feeding coal.It can be induced from this study that the unburned carbon in fly ashes comes primarily from the fines existed in the fed coal and produced by the attrition and fragmentation of coal particles,which cannot be totally burned in the earlier stage of combustion.The clarain,which is of high reactivity and frangible,may be the main originations of unburned carbon in fly ash.

Tiny Structure of Fly Ash and Experiment of Dry Removing Carbon in Fluidization Bed

The Micro Structure of Fly Ash and Dry Removing Carbon

Characteristics Experimental of Fly Ash Release in Combustion Process of Blended Coal

EXPERIMENTAL STUDY ON FLUIDIZED BED AGGLOMERATION COMBUSTION USING FLY-ASH SLURRY WITH HIGH CARBON CONTENT AND COAL-WATER MIXTURE AS FUELS

Experimental Study on Dry Decarbon Method of Fly Ash

Fluidized Bed Drying and Devolatilization of Lignite Washery Tailing Particles: Experiments and Modeling

Exploration of Removing Unburned Carbon from Fly Ash by Column Flotation

STUDY ON THE CFB FLY ASH COMPONENTS DISTRIBUTION BY GRAVITY SOLUTION SEPARATION

Research on Carbon Content in Fly Ash from Circulating Fluidized Bed Boilers

Experimentation Study on Removal Chlorine from Incineration Fly Ash by Washing Process

Study on Pore and Chemical Structure Characteristics of Atmospheric Circulating Fluidized Bed Coal Gasification Fly Ash

Theoretical and Experimental Investigation on the Characteristics of Fly‐ash Scrubbing in a Fixed Valve Tray Column

Removal of unburned carbon from fly ash using enhanced gravity separation and the comparison with froth flotation

Facile Route for Effective Separation and Full-Scale Recycling of Fly Ash and Unburned Carbon

Raman Spectroscopy and X-Ray Diffraction Analysis of the Structural Characteristics of Fluidized Bed Gasification Fly Ash

Separation of unburned carbon from coal fly ash: A review

Characterization of fly ash and unburned carbon from CFB boiler with burning Fujian anthracite

Reducing the Combustible in Fly Ash of Circulating Fluidized Bed Boiler

Recent Advances in a Study on the Utilization of Circulating Fluidized Bed (CFB) Ash Residue

Research on Remove Free Carbon in Silica Fume by Fluidized Bed

Experimental investigation on ash deposition of a bituminous coal during oxy-fuel combustion in a bench-scale fluidized bed