Abstract:Revealing the catalytic oxidation mechanism of volatile organic compounds (VOCs) is insightful for the development of efficient catalysts. However, because of the complicated interactions and a large number of intermediate species during the reactions, the analysis of the entire reaction mechanism (including the activation modes of reactant molecules and the rate-limiting step) remains a great challenge. Herein, the YMn2O5 mullite catalyst was proposed to demonstrate how to distinguish the deep oxidation difference among C3-C4 alkanes and olefins via combining experiments and theoretical calculations. The YMn2O5 catalyst prepared via the hydrothermal method displayed a superior catalytic behavior with a low T-90 temperature (C3H8 at 250 degrees C; C3H6 , C4H10, and C4H8 less than 200 degrees C) (1000 ppm of C3-C4 and 10% O-2 balanced with He, WHSV = 30 000 mL/g.h). The catalytic activity remained the same after continuous reaction for 100 h at 275 degrees C for each reactant. Overall, the YMn2O5 mullite catalyst exhibits excellent durability with no activity declines for 400 h. Combined with TPD, DRIFTS, XPS, and DFT analysis, surface oxygen species were found to be active for the oxidation. Owing to the difference of the HOMO induced partial charge distributions between alkanes and alkenes, the dehydrogenation of the end-site C-H of propane is the first step prior to the crucial conversion of acrylate over surface labile oxygen in an octahedral ligand unit. For propene oxidation, the C=C double bond is preferentially attacked by two surface oxygen atoms belonging to the octahedral and pyramid ligand units with the crucial step of acetate decomposition. These findings provide insights into the oxide catalyst design toward the complicated VOCs oxidation from a fundamental point of view.

Catalytic Mechanism of P-Xylene Liquild-Phase Oxidation

KINETICS OF P-Xylene LIQUID PHASE CATALYTIC OXIDATION(Ⅲ) CATALYST COMPOSITION AND CONCENTRATION

Optimum Ratio Of Co/Mn In The Liquid-Phase Catalytic Oxidation Of P-Xylene To Terephthalic Acid

Effect of Zr and Hf Additives on P-Xylene Liquid Phase Oxidation

KINETICS OF P-Xylene LIQUID PHASE CATALYTIC OXIDATION (Ⅳ)KINETICS FOR PX AND SOLVENT BURNING

Experiment Technique of P-Xylene Liquid Phase Catalytic Oxidation

Mechanism of Manganese Catalyst Precipitation in the Ox Idation of P-Xylene

Cstr Model for P-Xylene Oxidation Reactor

The Effect of Temperature and Oxygen Concentration on P-Xylene Oxidation

Kinetics of P-Xylene Liquid-Phase Catalytic Oxidation to Terephthalic Acid

KINETICS OF P-Xylene LIQUID PHASE CATALYTIC OXIDATION(I) REACTION MECHANISM AND KINETIC MODEL

Effect of oxygen volume fraction on p-xylene liquid phase catalytic oxidation

Modeling of the Co-Mn-Br Catalyzed Liquid Phase Oxidation of P-Xylene to Terephthalic Acid and M-Xylene to Isophthalic Acid

Novel CoMn2O4 As a Highly Efficient Catalyst for the Oxidation of O-, M-, P-Xylene: Preparation and Kinetic Study

Difference of Oxidation Mechanism Between Light C3–C4 Alkane and Alkene over Mullite YMn2O5 Oxides’ Catalyst

Experimental study on o-xylene monochloride liquid phase oxidation

Enhanced aromatics selectivity and stability in a coaromatization reaction over P/[ZnCr]/HZSM-5

Promoting Effect of Mn and Ti on the Structure and Performance of Co3O4 Catalysts for Oxidation of Dibromomethane

Catalytic Oxidation of Dibromomethane over Ti-modified Co3O4 Catalysts: Structure, Activity and Mechanism.

The performance and mechanism for the catalytic oxidation of dibromomethane (CH2Br2) over Co3O4/TiO2 catalysts

Kinetics of COx formation in the homogeneous metal/bromide‐catalyzed aerobic oxidation of p‐xylene