Abstract:This paper proposes a new technical process to utilize flue gas desulfurization (FGD) gypsum in fluidized beds. Gypsum is stable in the inert atmosphere and instable in the reducing atmosphere. Decomposing properties of gypsum in multiatmospheres were investigated in both a thermogravimetric analyzer (TGA) and a fluidized bed reactor. Results from the TGA showed that the initial decomposing temperatures of gypsum in all reducing atmospheres are about 800 C; however, the ratio between CaS and CaO in the product is influenced by CO concentration ([CO]). Higher [CO] is beneficial to speeding the decomposition. The analysis of mass spectrometer showed that part of CaS was oxidized to CaO when the atmosphere was changed from the reducing one with [CO] = 2% to the oxidizing one with 02 concentration of 0.6%, which was proved by the XRD analysis of the final product with content of CaO of 91.6%. Fluidized bed experiments were done in a hot, lab scale, bubbling reactor. Results showed that CO2 can increase the CaO content in the product by restraining the side production of CaS significantly. After gypsum decomposition in the reducing atmosphere, a certain amount of air was injected to change the atmosphere to oxidizing, and more SO2 was released. The present research proves that a multistage fluidized bed system with multiatmospheres is feasible for gypsum decomposition.

ANALYSIS OF COMPOSITIONS FOR GYDSUM PRODUCED FROM WET FLUE GAS DESULFURATION

Chemical phase analysis of flue gas desulfurization gypsum powder

An Analytic Method Featuring Calcium Balance during a Gas-solid Calcium-based Desulfuration Reaction

The image analysis and thermal-gravity study on the components of gypsum in the desulphurization productions from WFGD

Research on the Calculation Model of Chemical Composition for Dry/Semi-dry Flue Gas Desulfurization Products

Experimental Study of Limestone/Gypsum-based Wet Process Flue Gas Desulfuration

Economic and Technical Analysis on Combined Calcium Desulphurizer

Study of the Desulfurized Ash Characteristics of a Flue-gas Circulating Fluidized Bed

Analysis on Calcium Based Sulphur- fixation Reagent hydration Active

Experimental Research on Fluidization Characteristics of Desulfurization By-Product and Feasibility Analysis of Sulfur Recovery

Study on Characteristics of Desulphurizing Absorbent of Hydrated Carbide Slag and Lime

Experimental Studies on Decomposing Properties of Desulfurization Gypsum in a Thermogravimetric Analyzer and Multiatmosphere Fluidized Beds

Study on the Stability of Sulfate in Desulfurization Residues Produced by Dry and Semi-dry Methods During Heating Process

Elemental Sulfur Recovery from FGD Gypsum and Calcium Cyclic Utilization in Coal-Fired Power Plants

NON-CATALYTIC OXIDATION KINETICS OF CALCIUM SULFITE IN WET LIMESTONE-GYPSUM FGD PROCESS

Research on Sulfur Recovery from the Byproducts of Magnesia Wet Flue Gas Desulfurization

Experimental Investigation on Disposal of the Product from a Slurry Jet WFGD

Experimental investigation on desulfurization of hygrolimebased on thermal balance

Study of SO2 Removal Efficiency Influence Factors and Their Adjustment Method in Wet Flue Gas Desulphurization

ANALYSIS AND CALCULATION OF THE LIQUID PHASE SYSTEM IN LIMESTONE/GYPSUM WET FLUE GAS DESULFURATION PROCESS

Investigation on flue gas desulphurization activated by water spray in reactor