Abstract:The conditions of coal ignition and combustion with application of plasma ignition system have been studied experimentally. Research on plasma ignition of coal fuel flow was carried out on a pilot setup. The conditions were close to the industrial ones used for start-up of coal boilers. The operating range of the velocities of pulverized coal flow in the electric arc unit has been determined. It has been established that a stable process of ignition and further combustion of coal is possible at these flow velocities in the electric arc unit. The experimental setup was started up from a cold state and heated to a temperature of 1000°C; the start-up time did not exceed 200 s. Based on the obtained experimental results, an industrial prototype of plasma ignition system (PIS) was designed and tested with a TP-10 boiler with a capacity of 220 tons of steam per hour. The boiler was started up from a cold state by means of the PIS technology without use of fuel oil; the start-up time was 5 hours. After the pass of pulverized coal through the PIS, stable ignition and combustion of pulverized coal flame with a temperature of 1350°C was observed in the boiler. For the first time, a technology for ignition of pulverized coal boilers without use of fuel oil was created and implemented on the basis of a starting burner with plasma ignition of fuel. The technology features positive economic and environmental parameters in comparison with the widespread technology of starting up coal-fired boilers with liquid fuel combustion.

Research on Plasma Iginition Technique in Power Station Boiler

Application Study on Starting Mode Without Injecting Fuel Oil Gun to Face-fired Boilers

Thermal Pyrolysis Plasma Ignition Technology

STUDY ON ELIMINATING FIRE-CARRYING IN PRIMARY AIR JET ORIFICE BY ADMIXING EXHAUST GAS

Experimental Research On No-Oil Ignition Technique Of Pulverized Coal/Coal-Water-Slurry

AN APPROACH TO LIL-SAVING FOR IGNITION OF PULVERIZED COAL FIRED BOILERS

The Plasma Ignition Combustion System and Its Operation Analysis

Analysis and Application of Pulverized Coal Fired Boiler Fuel-efficient Firing Technique in Thermal Power Plant

Plasma Ignition System to Start Up Pulverized Coal Boilers: Experimental Simulation and Full-Scale Test

A Research on Ignition of a Boiler by Using Coke-Oven Gas Instead of Light Oil and Alternation of the Boiler

Research on Application of PC Directly Ignited with Little Quantity Gasified Oil Combustion

Principle and Experimental Study of Oxygen-Enriched High Temperature Air Combustion Burner

Development and Status Quo of Utility-boiler Pulverized-coal Direct-ignition Technologies in China

The Principle And Performance Analysis Of Oxygen-Enriched Oil-Saving Combustion Technology For Pulverized Coal Firing

Induction-heating ignition of pulverized coal stream

Experimental research on the fire-carrying problems in primary air nozzle of 125 MW units

Research on Ignition Performance of Vaporized Oil Gun

Ignition and Flame Stablization Test for W-flame Boiler with Double Cyclone Burner Using Tiny-oil Ignition Technology

Low Oil Consumption-based Ignition in Combination with a Rich/lean Combustion Burner As Applied on a 600 MW Boiler

Experimental Study on the Working Characteristics of a Pre-combustion AC Plasma Jet Igniter

Research on Working Characteristics of Pre-combustion Plasma Igniter