PCDD/Fs emission characteristics of medical waste incinerator during start-up procedure

Qi WANG,Jia CHEN,Chao WANG,Min LI,Tong CHEN,Shengyong LU,Xiaodong LI,Xuguang JIANG,Jianhua YAN

DOI: https://doi.org/10.11949/j.issn.0438-1157.20140995

2015-01-01

Abstract:In order to study the emissions of polychlorinated dibenzo-p-dioxins/polychlorinated dibenzofurans (PCDD/Fs) during the transient and steady conditions of a medical waste incinerator (MWI) in east China, PCDD/Fs distributions and emission rate under different operating conditions of MWI was investigated. Flue gas sampling of MWI was conducted in accordance with operating conditions, start-up 1, start-up 2, start-up 3 and start-up 4 (four samples), 12 h after start-up(after-start 1, after-start 2, two samples) and 24 h after start-up (after-start 3, after-start 4, two samples). The I-TEQ values of flue gas were 1.68 ng I-TEQ·m?3 at the end of start-up and 2.77 ng I-TEQ·m?3 at 12 h after start-up, while the I-TEQ values of fly ash was 4.5 ng I-TEQ·g?1. The average concentrations of the PCDD/Fs emissions at start-up (0.78 ng I-TEQ·m?3) and after-start (1.5 ng I-TEQ·m?3) exceeded the emission limit (0.5 ng I-TEQ·m?3) for MWIs in China. The PCDD/Fs concentrations at 24 h after start-up (after-start 3, after-start 4) were still above the emission limit, which was proved as a“memory emission”effect due to the start-up conditions. The PCDFs/PCDDs ratio ranged from 0.14 to 0.95 at the beginning of start-up and from 5.46 to 6.29 during the after-start process, which meant PCDFs were dominant in the flue gases of MWI. PCDD/Fs congener profiles of flue gas samples during start-up and after-start were characterized by higher chlorinated PCDD/Fs. The PCDD/Fs congener profiles of fly ash samples were similar to flue gases, also mainly dominated by 2,3,4,7,8-PeCDF. PCDD/Fs in particle phase at the beginning of start-up accounted for 50%, while gas phase PCDD/Fs accounted for over 90%at 12 h after start-up. The PCDD/Fs emission rates of flue gas during start-up were much higher than normal conditions. The highest emission rate was 58.1μg I-TEQ·h?1, 40 times higher than the normal level. The total PCDD/Fs emission during start-up was 0.785 mg I-TEQ. The start-up of this MWI was approximately three times per year, and the start-ups of MWI accounted for 28%of the whole year’s PCDD/Fs emission.