Abstract:The Protein-Le Chatelier (PLC) effects are investigated by using digital image correlation at a constant applied strain rate of 5.0010-3 s-1 and room temperature in Al-Mg alloys with Mg content values (wt.%) of 2.30, 4.57, 6.10 and 6.91 respectively in this study. Both the yield strength and the ultimate strength increase with increasing Mg content, which is generally called solution strengthening. Type of PLC band changes from A to B with increasing Mg content. In low Mg content (2.30%) alloy, the serration amplitude almost remains 1 MPa, while in each of high Mg content (4.57%, 6.10%, 6.91%) alloys it linearly increases with the strain increasing. The serration amplitude is found to increase with increasing Mg content and gradually reaches a saturated state. With the increase of Mg content, the period of PLC band for continuous propagation gradually reduces and the time when the PLC band location sudden jumps increases in the process of propagation. When the strain is small, the out-of-band deformation of alloy is inhomogeneous obviously. And the deformation inhomogeneity slightly decreases with increasing Mg content. DIC results indicate that the PLC bandwidth does not change with Mg content, while the maximum strain increment in the PLC band increases with increasing both Mg content and strain. Additionally, special periodic damped serrations are observed in the stress-time curve of the low Mg content (2.30%), the corresponding PLC band shows that the periodic changed serrations in the stress-time curve correspond to the transformation of the PLC band orientation. Besides, the PLC band propagates upward continuously both before and after the shift.

Portevin-Le Chatelier Effect of LA41 Magnesium Alloys

Plc Effect and Its Explanation of La41 Magnesium Alloys

The Portevin-Le Chatelier Effect in Al-Mg Alloy Investigated by Infrared Pyrometry

Serrated Flow and Abnormal Strain Rate Sensitivity of a Magnesium–lithium Alloy

Acoustic Emission Inspection of Portevin-Le Chatelier Effect and Deformation Mechanisms of Two Mg–Li–Al Alloys

Multiscale Analysis And Numerical Modeling Of The Portevin-Le Chatelier Effect

Experimental Investigation on the Influence of Mg Content on Portevin-Le Chatelier Effect in Al-Based Alloys by Using Digital Image Correlation

The Twin Mechanism of Portevin Le Chatelier in Mg–5Li–3Al–1.5Zn–2RE Alloy

The Influence of Temperature on the PLC Effect in Al-Mg Alloy

A Critical Review on the Portevin-Le Chatelier Effect in Aluminum Alloys

Investigation of Portevin–Le Chatelier Band Strain and Elastic Shrinkage in Al-Based Alloys Associated with Mg Contents

A Macroscopic Model for the Portevin-Le Chatelier Effect

The effect of high solid solution Mg contents (7–13 wt%) on the dynamic strain aging behavior of Al–Mg alloys

Investigation of Portevin–Le Chatelier Effect in Rolled Α-Phase Mg-Li Alloy During Tensile and Compressive Deformation

The Portevin-Le Chatelier Effect and Creep Behaviour in A Mg-Ca-Zn-Zr Alloy

Compression Behavior of Magnesium-Lithium Alloy at Room Temperature

The Portevin-Le Chatelier Effect in Corrosion Behavior of the Mg-Zn-Sr Alloy

Portevin-Le Chatelier Characterization of Annealed Al-Mg Alloy Sheets with Different Mg Contents

On the Role of Zr Content into Portevin-Le Chatelier (PLC) Effect of Selective Laser Melted High Strength Al-Cu-Mg-Mn Alloy

Fracture behavior of a rapidly solidified thin-strip continuous cast AA5182 Al-Mg alloy with the Portevin-Le Chatelier effect under varying strain rates

Effect of Solute Concentration on Portevin-Le Chatelier Effect in Al-Cu Alloys