Abstract:The SO2/NOX pollution in the flue gas of non-ferrous smelting is increasingly serious. At the same time, the accumulation of red mud (RM) in the aluminum industry and phosphorus sludge (PS) in the yellow phosphorus industry has caused serious harm to the environment. To remove SO2 and NOX from the non-ferrous smelting flue gas and realize the resource utilization of the above two solid wastes, an ultrasonic field was used in this study to strengthen the PS excited O3 process and RM wet desulfurization and denitrification process. In the process of O3 excitation, the response surface method (RSM) is used to obtain the optimal O3 excitation concentration, and the optimal reaction conditions are designed based on the response surface optimization model: T is 53.226 °C, power density is 0.4 W/cm2, PS concentration is 51.433 g/L, O3 formation concentration up to 250 ppm or more, which provides a theoretical basis for subsequent desulfurization and denitrification steps. It is proved that this study can replace the expensive traditional O3 generator and provide a basis for NOX removal in the following process. In addition, the optimum experimental conditions of ultrasonic enhanced RM desulfurization and denitrification process were also explored. Under ultrasonic frequency of 28 kHz, ultrasonic power density of 0.4 W/cm2, T of 50 °C, RM concentration of 15 g/L, and stirring intensity of 1000 rpm, the desulfurization efficiency of the reaction system can be maintained above 95 % within 250 min, and the denitrification efficiency can be maintained above 90 % within 250 min. The effect of desulfurization and denitrification in this study is much better than that of traditional methods. Finally, the reaction mechanism of ultrasonic enhanced O3 excitation and RM wet desulfurization and nitrogen removal was discussed by combining adsorption thermodynamics, isotherm, and kinetics. The results showed that the OH· free radicals generated by ultrasonic cavitation and the physical effects brought by emulsification had significant promoting effects.

Pretreatment of Shale Gas Drilling Flowback Fluid (sgdf) by the Microscale Fe-0/Persulfate/O-3 Process (Mfe(0)/ps/o-3)

Pretreatment of shale gas flowback water (SGFW) by hydroxylamine and FexOy/γ-Al2O3 synergistic catalytic ozone oxidation (HSCO)

Performances and mechanisms of the peroxymonosulfate/ferrate(VI) oxidation process in real shale gas flowback water treatment

Performances and mechanisms of ferrate(VI) oxidation process for shale gas flowback water treatment

Efficient removal of organic contaminants in real shale gas flowback water using Fenton oxidation assisted by UV irradiation: Feasibility study and process optimization

Can pre-ozonation be combined with gravity-driven membrane filtration to treat shale gas wastewater?

A New Environment-Friendly Polyferric Sulfate-Catalyzed Ozonation Process for Sludge Conditioning to Achieve Deep Dewatering and Simultaneous Detoxification

Ultrasonic-enhanced Phosphorus Sludge Excited O3 Coupled Red Mud Simultaneous Desulfurization and Denitrification

Enhanced organic removal for shale gas fracturing flowback water by electrocoagulation and simultaneous electro-peroxone process

Improved Ultrafiltration Performance Through Dielectric Barrier Discharge/sulfite Pretreatment: Effects of Water Matrices and Mechanistic Insights

Sludge Treatment by O-3/H2o2 and Carbon Source Recovery

Fertilizer-driven FO and MD integrated process for shale gas produced water treatment: Draw solution evaluation and PAC enhancement

Oxidation-biotreatment-membrane combined process for external reuse of shale gas wastewater

Enhanced Mitigation of Membrane Fouling and Degradation of Perfluorooctanoic Acid in the Treatment of Natural Surface Water Through the Application of Dielectric Barrier Discharge/sulfite

Membrane fouling alleviation by combination of sodium percarbonate oxidation and coagulation during microfiltration of shale gas produced water

Application of Coagulation-Uf Hybrid Process for Shale Gas Fracturing Flowback Water Recycling: Performance and Fouling Analysis

Improving membrane distillation performance by Fe(II) activated sodium percarbonate oxidation during the treatment of shale gas produced water

Optimization of the O3/H2O2 process with response surface methodology for pretreatment of mother liquor of gas field wastewater

Synergistic Mechanism of Combined Ferrate and Ultrafiltration Process for Shale Gas Wastewater Treatment

Exploration of ferrate (VI) pretreatment and ultrasonication combined with gravity-driven membrane filtration for shale gas wastewater treatment

Treatment of Hydraulic Fracturing Flowback Water Using the Combination of Gel Breaking, Magnetic-Enhanced Coagulation, and Electrocatalytic Oxidation