Abstract:Water decontamination from fluoride is still a challenging task of global concern. Recently, Al-based layered double hydroxides (LDHs) have been extensively studied for specific fluoride adsorption from water. Unfortunately, they cannot be readily applied in scaled-up application due to their ultrafine particles as well as the regeneration issues caused by their poor stability at alkaline pHs. Here, we developed a novel (LDH)-based hybrid adsorbent, i.e., LALDH-201, by impregnating nanocrystalline Li/Al LDHs (LADLH) inside a commercial polystyrene anion exchanger D201. TEM image and XRD spectra of the resultant nanocomposite confirmed that the LDHs particles were nanosized inside the pores of D201 of highly crystalline nature and well-ordered layer structure. After impregnation, the chemical and mechanical stability of LALDH were significantly improved against pH variation, facilitating its application at a wide pH range (3.5-12). Fluoride adsorption onto LALDH-201 was compared to D201 and activated alumina, evidencing the preferable removal fluoride of LALDH-201. Fluoride adsorption onto LALDH-201 followed pseudo-second-order model, with the maximum capacity (62.5 mg/g from the Sips model) much higher than the other two adsorbents. Fixed-bed adsorption run indicated the qualified treatable volume of the fluoride contaminated groundwater (4.1 mg/L initially) with LALDH-201 was about 11 times as much as with the anion exchanger D201 when the breakthrough point was set as 1.5 mg/L. The capacity of LALDH-201 could be effectively refreshed for continuous column operation without observable loss by using the mixed solution of 0.01 M NaOH + 1 M NaCl. The above results suggested that the hybrid adsorbent LALDH-201 is very promising for water defluoridation in scaled-up application. (C) 2016 Elsevier Ltd. All rights reserved.

Preparation of High-purity Lactulose through Efficient Recycle of Catalyst Sodium Aluminate and Nanofiltration: A Pilot-scale Purification.

Entrainer-intensified Vacuum Reactive Distillation Process for the Separation of 5-Hydroxylmethylfurfural from the Dehydration of Carbohydrates Catalyzed by a Metal Salt–ionic Liquid

Desalting and Recovering Naphthalenesulfonic Acid from Wastewater with Concentrated Bivalent Salt by Nanofiltration Process

Fabrication of Cellulose Nanofiltration Membranes by Reusing a Binary Solvent of EMIMAc Ionic Liquid and DMSO

Hybrid Nanofiltration–membrane Crystallization System for the Treatment of Sulfate Wastes

Lactose Mother Liquor Stream Valorisation Using an Effective Electrodialytic Process

Two-stage Nanofiltration Process for High-Value Chemical Production from Hydrolysates of Lignocellulosic Biomass Through Hydrothermal Liquefaction

Selective Separation of Chloride and Sulfate by Nanofiltration for High Saline Wastewater Recycling

Study On Nanofiltration For Purifying Fructo-Oligosaccharides: Process Simulation And Optimization

Fabrication of Thin-Film Composite Nanofiltration Membranes with Improved Performance Using Β-Cyclodextrin As Monomer for Efficient Separation of Dye/salt Mixtures

Study on nanofiltration for purifying fructo-oligosaccharides I. Operation modes

Efficient Defluoridation of Water Using Reusable Nanocrystalline Layered Double Hydroxides Impregnated Polystyrene Anion Exchanger.

Highly Efficient and Solvent-Free Purification Technique and Model Study of Layer Melt Crystallization

Preparation of L-Butyl Lactate Via Transesterification by Using Nafion-H Catalyst

Development of a sustainable route for the production of high-fructose syrup from the polyfructan inulin

Purification and fractionation of cellooligosaccharides synthesized from controlled cellulose hydrolysis by sulfuric acid using nanofiltration

Development of eco-friendly coating for the fabrication of high performing loose nanofiltration membranes for dye-contaminated wastewater treatment

Synthesizing high performance robust PSf loose nanofiltration membranes through nanobubble-assisted pore-forming

Purification of lactulose from mixtures with lactose using pressurized liquid extraction with ethanol-water at different temperatures

Chemoselective precipitation of lactose from a lactose/sucrose mixture: proof of concept for a new separation methodology

Purification of Lactic Acid by Heterogeneous Catalytic Distillation Using Ion-Exchange Resins