Abstract:The evaporation of aviation kerosene droplets in the aeroengine combustion chamber is one of the basic processes during liquid fuel combustion, which directly affects fuel atomization, air-fuel mixture formation and the combustion quality. However, the data are rarely reported due to the difficulty of conducting experiments in high temperature and pressure conditions. In this study, a series of experiments were carried out to investigate the evaporation characteristics of RP-3 aviation kerosene droplet. The environmental pressure and temperature of droplet evaporation ranged from 1 and 20 bar and 400 and 600 °C respectively. An individual RP-3 kerosene droplet with initial diameter between 0.9 and 1.1 mm was suspended at a thermocouple bead with 50 μm diameter to measure droplet temperature. Droplet diameter during the whole evaporation process was recorded simultaneously by a high-speed camera. Experimental results indicated that at lower evaporation rate, RP-3 kerosene droplet evaporation experienced two processes: transient heating and equilibrium evaporation periods. While under high evaporation rates, the droplet only underwent equilibrium evaporation period without droplet expansion. At all the studied temperatures, droplet temperature kept increasing during the entire evaporation process without reaching a stable temperature. In most cases, the transient evaporation rate ( K ) of RP-3 kerosene droplet first increased rapidly until reaching the peak, and then followed by a monotonous decrease. However, at 20 bar above 500 °C conditions, the temporal K curve exhibited a double-peak feature. Above the critical temperature of the fuel, increasing ambient pressure and temperature both can promote the heating and evaporation. However, the promotion of increasing ambient temperature to droplet evaporation was weakened at high ambient pressure. The quantitative correlations of droplet lifetime and evaporation rate constant with pressure were proposed under different ambient temperatures.

Measurement of Isobaric Specific Heat of Emulsified Kerosene at Supercritical Pressure

Isobaric Heat Capacity Measurements for Dimethyl Ether and 1,1-Difluoroethane in the Liquid Phase at Temperatures from 305 K to 365 K and Pressures Up to 5 Mpa

Measurements of Isobaric Heat Capacity of R143a and R227ea at Liquid Phase by Quasi-Steady Scanning

MEASUREMENT OF HEAT SINK FOR ENDOTHERMIC FUELS

Measurements of the Isobaric Heat Capacity of Pressurized Liquid Trans-1,3,3,3-tetrafluoropropene [r1234ze(e)] by Scanning Calorimetry

Measurements of Coefficient of Convective Heat Transfer for Endothermic Hydrocarbon Fuel Up to Supercritical Pressures

Numerical Study on Heat Transfer Characteristics of Emulsified Kerosene at Supercritical Pressure

Modeling and Simulation of Supercritical-Pressure Turbulent Heat Transfer of Aviation Kerosene with Detailed Pyrolytic Chemical Reactions

Analyses of Surrogate Models for Calculating Thermophysical Properties of Aviation Kerosene RP-3 at Supercritical Pressures

Numerical Study of Fluid Flows and Heat Transfer of Aviation Kerosene with Consideration of Fuel Pyrolysis and Surface Coking at Supercritical Pressures

Asymmetric Heating and Buoyancy Effects on Heat Transfer of Hydrocarbon Fuel in a Horizontal Square Channel at Supercritical Pressures

Experimental investigation on evaporation characteristics of RP-3 aviation kerosene droplet above the critical temperature under various pressure conditions

Model Validation and Parametric Study of Fluid Flows and Heat Transfer of Aviation Kerosene with Endothermic Pyrolysis at Supercritical Pressure

Numerical Study on Turbulent Convective Heat Transfer with n-heptane Under Supercritical Pressures

Conjugate Heat Transfer, Endothermic Fuel Pyrolysis and Surface Coking of Aviation Kerosene in Ribbed Tube at Supercritical Pressure

Experimental Study on Heat Transfer of Aviation Kerosene in a Vertical Upward Tube at Supercritical Pressures

Measurements on vapor pressure and thermal conductivity for pseudo-binary systems of a hydrocarbon fuel with ethylene and diethylene glycol dimethyl ethers

Isobaric Heat Capacities of R245fa and R236fa in Liquid Phase at Temperatures from (315 to 365) K and Pressures Up to 5.5 MPa

Calorimetric Determination of the Vapor Heat Capacity of Petroleum Cuts

Measurement of Interacting Ethanol Droplets Evaporation at Moderately Elevated Temperature and Pressure Using Phase Rainbow Refractometry

Numerical Study of Heat Transfer Characteristics of Downward Supercritical Kerosene Flow Inside Circular Tubes