Abstract:With the continued device scaling and the introduction of new device structures, MOSFET reliability phenomena arising from the hot carrier injection (HCI) stress have received extensive attention from both the academia and the industry community. In this work, the degradations of ultra-scaled silicon on insulator (SOI) MOSFETs under the HCI stress are investigated on devices of different gate lengths (L=30-150 nm). Our experimental data demonstrate that the time evolutions of the threshold voltage change (Vth) under the HCI stress for different gate length devices are the same, and the magnitude of Vth reduces for the shorter devices. The degradation of the device under the HCI stress should be due to both the channel hot carrier (CHC) effect and the bias temperature instability (BTI) effect. The distribution and magnitude of the electric field along the MOSFET's channel are analyzed. It is confirmed that besides the well-known CHC effect in the depletion region close to the drain side, a strong BTI effect co-exists in the channel close to the source side. This degradation mechanism is different from the conventional HCI stress. With the gate length decreasing, the contribution of the aforementioned BTI effect becomes larger, and it dominates in the degradation. One feature of the BTI effects is that the corresponding degradation is small when the gate length is short. This is consistent with our experimental result that the change of Vth is small for the device of short gate length under the accelerated HCI stress. The time evolution of Vth can be described by the equation Vth=A•tn, where A is a constant, t is the stress time, and n is the power law exponent obtained by the curve fitting. In this study, the power law exponent n of pMOSFET is larger than that of nMOSFET. This experimental fact can lead to the point that the BTI effect exists during the HCI stress because the BTI effect in ultra-scaled pMOSFETs is more significant than that in nMOSFETs. The stress-recover experiments of the HCI stress on MOSFTTs show larger recovery in device of shorter gate length. It is found that the ratio of the recovery to the total degradation in the 30 nm gate-length device is almost twice as large as that in the 150 nm device. The degradation from the CHC effect has no recovery, and the larger recovery in the shorter-channel device implies the larger component of the BTI degradation. Another intriguing fact is that our experimental result on SOI MOSFET is inconsistent with the recently reported result on FinFET. We argue that the reported stronger HCI degradation in FinFET may not be ascribed only to the stronger electric field in the shorter channel, but also to the fact that the FinFET' channel is three-dimensionally surrounded by the gate dielectric. This kind of three-dimensional structure significantly increases the chance for electrons or holes to be injected into the dielectric layer. Therefore the HCI reliability of planar SOI MOSFETs may be better than that of FinFETs at the same level of gate length. In conclusion, the BTI effect is an important source of the degradation during the HCI stress in ultra-short-channel device, and it is no more negligible in analyzing the underlying physical mechanism.

The Effect of Ionization and Displacement Damage on Minority Carrier Lifetime

Hydrogen Soaking, Displacement Damage Effects, and Charge Yield in Gated Lateral Bipolar Junction Transistors

Influence of LDD Spacers and H+Transport on the Total-Ionizing-Dose Response of 65-Nm MOSFETs Irradiated to Ultrahigh Doses

Ionization damage behavior of gate controlled lateral PNP(GLPNP) transistors in H2 environment

The Effects of Displacement Damage on Ionization Effect in SiO2 Layer of Bipolar Transistor

Gate Bias and Length Dependences of Total Ionizing Dose Effects in InGaAs FinFETs on Bulk Si

The Influence of Deep-Level Defects With Various Depths in SiO<sub>2</sub> on Ionizing Damage

Effects of impurities and defects on the distribution of minority carrier lifetime in multi-crystalline silicon

Effect of Electric Field on Radiation Defects in NPN Transistors

Effect of H2 on Interface Traps in the LPNP Transistors Caused by 3 MeV Proton Irradiations

Synergistic Effect of Ionization and Displacement Defects in Npn Transistors Induced by 40-Mev Si Ion Irradiation with Low Fluence

Statistical Analysis on the Effects of Heavy Ion Irradiation on 65 Nm Bulk Silicon MOS Devices

Effect of Protons Located at Different Region in SiO2 Layer on GLPNP Transistors Degradation

A Direct Evidence of the Annealing Effect of Ionization Damage on Displacement Damage in NPN Transistors

Gate Length Dependence of Hot Carrier Injection Degradation in Short Channel Silicon on Insulator Planar Mosfet

Total-Ionizing-Dose Effects and Low-Frequency Noise in 30-Nm Gate-Length Bulk and SOI FinFETs with SiO2/HfO2Gate Dielectrics

Analysis of Displacement Damage Induced by Silicon-Ion Irradiation in SiC MOSFETs

The Effect of Ionization Damage on Displacement Damage in AlGaN/GaN HEMTs

Dry Etch Damage in N-Type Crystalline Silicon Wafers Assessed by Deep-Level Transient Spectroscopy and Minority Carrier Lifetime

Impact of nitride passivation layer on ionizing irradiation damage on LPNP bipolar transistors

Synergistic Effects of Ionizing Dose and Displacement Damage on SiGe Heterojunction Bipolar Transistors