Abstract:Conventional wet-process phosphoric acid (WPA) extraction route encounters unsatisfactory extraction efficiency, phosphorus yield, and raffinate utilization. Herein, a new extraction route for H3PO4 separation from wet-process superphosphoric acid (WSPA) is proposed to improve these dilemmas. We focus on the equilibrium of H3PO4 extraction by tributyl phosphate (TBP) from WSPA and the extraction mechanism of TBP under high H3PO4 loading conditions. Several critical factors affecting the extraction equilibrium were investigated to optimize the extraction process, including the initial phase ratio (R0), the volume fraction of TBP in extradant (φTBP), temperature (T), and the crosscurrent extraction stages. The results show that the single-stage extraction rate of H3PO4 reaches 70% at R0=6, φTBP=80% and T=80oC with separation factors βP/Fe, βP/Al, βP/Mg, and βP/Ca of 12.48, 21.66, 47.57, and 8.89, respectively. In addition, Fourier transform infrared spectroscopy and Raman spectroscopy enlighten the extraction mechanism at high loading conditions. The characteristic peak positions of P=O, P=O⋯H2O, and P=O⋯H3PO4 in the infrared spectra are determined to be centered at 1,283, 1,267, and 1,233 cm−1, respectively. The semi-quantitative analysis implies that the self-polymerization behavior of the extraction complex TBP·H3PO4 and the mutual attraction of reverse micelles (RMs) through their polar cores is the trigger for the formation of a third phase. Furthermore, the red shift of P-(OH)3 asymmetrical stretching vibration in the Raman spectrum indicates the formation of hydrogen bonds among H3PO4 molecules in the organic phase, which corroborates the formation of RMs. Conclusions can be obtained that H3PO4 enters the organic phase under high loading capacity by reversed micellar extraction. The feasibility of this extraction process is further tested by scrubbing, stripping, and cycling performance experiments. The results are promising for the design of a new efficient route for separating H3PO4 from WPA.

Separation of H3PO4 from HCl-wet-processing phosphate rocks leach liquor by TBP: Extraction equilibria and mechanism study

A non-aqueous phase extraction system using tributyl phosphate for H3PO4 separation from wet-process superphosphoric acid: Extraction equilibrium and mechanism

Study on solubility parameter of TBP/MIBK and phase equilibrium of TM/H3PO4/H2O

Experimental Study on the Mechanism and Thermodynamics of Extraction of Fe 3+ from Phosphoric Acid Solution

Structure and aggregation behavior of pertechnetate/perrhenate in organic phase in the extraction by tributyl phosphate

Liquid-liquid equilibrium in the system phosphoric acid/water/tri-n-butyl phosphate/calcium chloride

Extraction of Inorganic Acids with Neutral Phosphorus Extractants Based on a Reverse Micelle/microemulsion Mechanism.

Extraction kinetics of nitric acid from the nitric acid-hydrochloric acid-potassium chloride solution by tributyl phosphate

Extraction Equilibria of Lithium with Tributyl Phosphate in Three Diluents

Extraction Equilibria of Lithium with Tributyl Phosphate in Kerosene and FeCl 3

Extraction Equilibria of Formic and Acetic Acids from Aqueous Solution by Phosphate-Containing Extractants

Selective Separation of HNO 3 and HCl by Extraction: The Investigation on the Noncovalent Interaction between Extractants and Acids by Density Functional Theory

Wet process phosphoric acid purification by solvent extraction using N-octanol and tributylphosphate mixtures

Extraction of Lithium from Brine Containing High Concentration of Magnesium by Tri-N-Butyl Phosphate Dissolved in Kerosene

Experimental study on extraction of scandium from hydrochloride acid leaching liquid in TBP

Rapid separation of High-viscosity phosphorous Acid/Tributyl phosphate extraction system by a stable anticorrosive Super-PA-phobic mesh

Extraction of Fe3+ from NaH2PO4 Solution in a Spiral Microchannel Device

Solvent extraction of titanium from the simulated ilmenite sulfuric acid leachate by trialkylphosphine oxide

Removal of Fluorine from Wet-Process Phosphoric Acid Using a Solvent Extraction Technique with Tributyl Phosphate and Silicon Oil

Extraction of Glyoxylic Acid, Glycolic Acid, Acrylic Acid, and Benzoic Acid with Trialkylphosphine Oxide