Abstract:Conventional wet-process phosphoric acid (WPA) extraction route encounters unsatisfactory extraction efficiency, phosphorus yield, and raffinate utilization. Herein, a new extraction route for H3PO4 separation from wet-process superphosphoric acid (WSPA) is proposed to improve these dilemmas. We focus on the equilibrium of H3PO4 extraction by tributyl phosphate (TBP) from WSPA and the extraction mechanism of TBP under high H3PO4 loading conditions. Several critical factors affecting the extraction equilibrium were investigated to optimize the extraction process, including the initial phase ratio (R0), the volume fraction of TBP in extradant (φTBP), temperature (T), and the crosscurrent extraction stages. The results show that the single-stage extraction rate of H3PO4 reaches 70% at R0=6, φTBP=80% and T=80oC with separation factors βP/Fe, βP/Al, βP/Mg, and βP/Ca of 12.48, 21.66, 47.57, and 8.89, respectively. In addition, Fourier transform infrared spectroscopy and Raman spectroscopy enlighten the extraction mechanism at high loading conditions. The characteristic peak positions of P=O, P=O⋯H2O, and P=O⋯H3PO4 in the infrared spectra are determined to be centered at 1,283, 1,267, and 1,233 cm−1, respectively. The semi-quantitative analysis implies that the self-polymerization behavior of the extraction complex TBP·H3PO4 and the mutual attraction of reverse micelles (RMs) through their polar cores is the trigger for the formation of a third phase. Furthermore, the red shift of P-(OH)3 asymmetrical stretching vibration in the Raman spectrum indicates the formation of hydrogen bonds among H3PO4 molecules in the organic phase, which corroborates the formation of RMs. Conclusions can be obtained that H3PO4 enters the organic phase under high loading capacity by reversed micellar extraction. The feasibility of this extraction process is further tested by scrubbing, stripping, and cycling performance experiments. The results are promising for the design of a new efficient route for separating H3PO4 from WPA.

Extraction of Inorganic Acids with Neutral Phosphorus Extractants Based on a Reverse Micelle/microemulsion Mechanism.

Selective Separation of HNO 3 and HCl by Extraction: The Investigation on the Noncovalent Interaction between Extractants and Acids by Density Functional Theory

Experimental Study on the Mechanism and Thermodynamics of Extraction of Fe 3+ from Phosphoric Acid Solution

Organophosphorus Extractants: A Critical Choice for Actinides/Lanthanides Separation in Nuclear Fuel Cycle

A non-aqueous phase extraction system using tributyl phosphate for H3PO4 separation from wet-process superphosphoric acid: Extraction equilibrium and mechanism

Synthesis of organic phosphinic acids and studies on the relationship between their structure and extraction-separation performance of heavy rare earths from HNO3 solutions

Reactive extraction equilibria behavior of monocarboxylic acids by trialkyl phosphine oxide

Wet process phosphoric acid purification by solvent extraction using N-octanol and tributylphosphate mixtures

Fourier Transform Infrared Characterization of the Acidic Phosphoric Extractant System Containing Lanthanide

Mechanism of trivalent actinide/lanthanide separation using synergistic mixtures of di(chlorophenyl)dithiophosphinic acid and neutral O-bearing co-extractants

MECHANISM OF THE EXTRACTANT LOSS IN LANTHANIDE EXTRACTION PROCESS WITH SAPONIFIED ORGANOPHOSPHORUS ACID EXTRACTION SYSTEMS — II: FORMATION OF AQUEOUS AGGREGATES

Extraction Equilibria of Formic and Acetic Acids from Aqueous Solution by Phosphate-Containing Extractants

Separation of H3PO4 from HCl-wet-processing phosphate rocks leach liquor by TBP: Extraction equilibria and mechanism study

Comparative Study of Four Acidic Extractants as Modifiers in the TBP/FeCl 3 Solvent Extraction System for Lithium and Magnesium Separation

Removal of Fluorine from Wet-Process Phosphoric Acid Using a Solvent Extraction Technique with Tributyl Phosphate and Silicon Oil

Investigation of aggregation in solvent extraction of lanthanides by acidic extractants (organophosphorus and naphthenic acid)

Complex extraction and stripping of H acid wastewater

Extraction Equilibria of Monocarboxylic Acids with Trialkylphosphine Oxide

Mechanism of extraction for carboxylic acid with tri-n-octylamine (2). Effects of pKa and hydrophobicity

Extraction Equilibria of Glycolic and Glyoxylic Acids with Trialkylphosphine Oxide and Trioctylamine As Extractant