Abstract:Conventional wet-process phosphoric acid (WPA) extraction route encounters unsatisfactory extraction efficiency, phosphorus yield, and raffinate utilization. Herein, a new extraction route for H3PO4 separation from wet-process superphosphoric acid (WSPA) is proposed to improve these dilemmas. We focus on the equilibrium of H3PO4 extraction by tributyl phosphate (TBP) from WSPA and the extraction mechanism of TBP under high H3PO4 loading conditions. Several critical factors affecting the extraction equilibrium were investigated to optimize the extraction process, including the initial phase ratio (R0), the volume fraction of TBP in extradant (φTBP), temperature (T), and the crosscurrent extraction stages. The results show that the single-stage extraction rate of H3PO4 reaches 70% at R0=6, φTBP=80% and T=80oC with separation factors βP/Fe, βP/Al, βP/Mg, and βP/Ca of 12.48, 21.66, 47.57, and 8.89, respectively. In addition, Fourier transform infrared spectroscopy and Raman spectroscopy enlighten the extraction mechanism at high loading conditions. The characteristic peak positions of P=O, P=O⋯H2O, and P=O⋯H3PO4 in the infrared spectra are determined to be centered at 1,283, 1,267, and 1,233 cm−1, respectively. The semi-quantitative analysis implies that the self-polymerization behavior of the extraction complex TBP·H3PO4 and the mutual attraction of reverse micelles (RMs) through their polar cores is the trigger for the formation of a third phase. Furthermore, the red shift of P-(OH)3 asymmetrical stretching vibration in the Raman spectrum indicates the formation of hydrogen bonds among H3PO4 molecules in the organic phase, which corroborates the formation of RMs. Conclusions can be obtained that H3PO4 enters the organic phase under high loading capacity by reversed micellar extraction. The feasibility of this extraction process is further tested by scrubbing, stripping, and cycling performance experiments. The results are promising for the design of a new efficient route for separating H3PO4 from WPA.

Wet process phosphoric acid purification by solvent extraction using N-octanol and tributylphosphate mixtures

Non-dispersive Solvent Extraction of P-Toluic Acid from Purified Terephthalic Acid Plant Wastewater with P-Xylene As Extractant

Purification of Phosphoric Acid by Solvent Extraction

A New Process for Purifying Wet-Process Phosphoric Acid by Solvent Extraction

Optimization of operating conditions in purification of wet process phosphoric acid in a liquid-liquid extraction column

Removal of Fluorine from Wet-Process Phosphoric Acid Using a Solvent Extraction Technique with Tributyl Phosphate and Silicon Oil

A non-aqueous phase extraction system using tributyl phosphate for H3PO4 separation from wet-process superphosphoric acid: Extraction equilibrium and mechanism

Novel Synergistic Process of Impurities Extraction and Phophogypsum Crystallization Control in Wet-Process Phosphoric Acid

Phosphoric Acid Purification by Suspension Melt Crystallization: Parametric Study of the Crystallization and Sweating Steps

Extraction and separation of tungsten from acidic high-phosphorus solution

Recovery of Fumaric Acid from Industrial Wastewater by Chemical Extraction and Stripping

Complex extraction and stripping of H acid wastewater

Experimental Study on the Mechanism and Thermodynamics of Extraction of Fe 3+ from Phosphoric Acid Solution

Extraction of Inorganic Acids with Neutral Phosphorus Extractants Based on a Reverse Micelle/microemulsion Mechanism.

Concentrating phosphoric acid by direct contact membrane distillation using a low-cost polyethylene separator

Extraction of Rare Earth Metals by Solid-Phase Extractants from Phosphoric Acid Solution

Phosphorus removal and recovery from polytetrahydrofuran wastewater by solventing-out crystallization

Viscosity of the Tributyl Phosphate + Methyl Isobutyl Ketone + Phosphoric Acid System

Raman spectroscopy and molecular dynamics simulations of aqueous two-phase systems for the purification of phosphoric acid.

Rapid separation of High-viscosity phosphorous Acid/Tributyl phosphate extraction system by a stable anticorrosive Super-PA-phobic mesh