Abstract:Conventional wet-process phosphoric acid (WPA) extraction route encounters unsatisfactory extraction efficiency, phosphorus yield, and raffinate utilization. Herein, a new extraction route for H3PO4 separation from wet-process superphosphoric acid (WSPA) is proposed to improve these dilemmas. We focus on the equilibrium of H3PO4 extraction by tributyl phosphate (TBP) from WSPA and the extraction mechanism of TBP under high H3PO4 loading conditions. Several critical factors affecting the extraction equilibrium were investigated to optimize the extraction process, including the initial phase ratio (R0), the volume fraction of TBP in extradant (φTBP), temperature (T), and the crosscurrent extraction stages. The results show that the single-stage extraction rate of H3PO4 reaches 70% at R0=6, φTBP=80% and T=80oC with separation factors βP/Fe, βP/Al, βP/Mg, and βP/Ca of 12.48, 21.66, 47.57, and 8.89, respectively. In addition, Fourier transform infrared spectroscopy and Raman spectroscopy enlighten the extraction mechanism at high loading conditions. The characteristic peak positions of P=O, P=O⋯H2O, and P=O⋯H3PO4 in the infrared spectra are determined to be centered at 1,283, 1,267, and 1,233 cm−1, respectively. The semi-quantitative analysis implies that the self-polymerization behavior of the extraction complex TBP·H3PO4 and the mutual attraction of reverse micelles (RMs) through their polar cores is the trigger for the formation of a third phase. Furthermore, the red shift of P-(OH)3 asymmetrical stretching vibration in the Raman spectrum indicates the formation of hydrogen bonds among H3PO4 molecules in the organic phase, which corroborates the formation of RMs. Conclusions can be obtained that H3PO4 enters the organic phase under high loading capacity by reversed micellar extraction. The feasibility of this extraction process is further tested by scrubbing, stripping, and cycling performance experiments. The results are promising for the design of a new efficient route for separating H3PO4 from WPA.

Viscosity of the Tributyl Phosphate + Methyl Isobutyl Ketone + Phosphoric Acid System

Density and Viscosity of Tributyl Phosphate + Kerosene + Phosphoric Acid from (20 to 60) °C

Wet process phosphoric acid purification by solvent extraction using N-octanol and tributylphosphate mixtures

Isobaric Vapor–Liquid Equilibria for Water + Acetic Acid + 1-Ethyl-3-methylimidazolium Diethylphosphate at 101.32 Kpa

Effect of the Permeants/Polymer Interactions on the Pervaporative Separation Properties of the P(Vdf-Co-Hfp) Membrane

Influence of Viscosity Slope Coefficient of CA and Its Blends in Dilute Solutions on Permeation Flux of Their Films for MeOH/MTBE Mixture

Study on solubility parameter of TBP/MIBK and phase equilibrium of TM/H3PO4/H2O

Extraction Equilibria of Benzoic Acid with Tributyl Phosphate in Kerosene and 1-Octanol

Mixing Properties of Tris(2-ethylhexyl) Phosphate with Alkanes at Different Temperatures and Data Treatment Using Several Correlation Equations Based on Eyring's Absolute Reaction Theory

Transesterification of Methyl Oleate for Sustainable Production of Biolubricant: Process Optimization and Kinetic Study

Research on Air Content Estimation of Tributyl Phosphate Hydraulic Fluids: A Novel Approach Based on the Vacuum Method

Pervaporation Recovery of Acetone-Butanol from Aqueous Solution and Fermentation Broth Using Htpb-Based Polyurethaneurea Membranes

Biolubricant Production of 2‐ethylhexyl Palmitate by Transesterification over Unsupported Potassium Carbonate

Measurement and Correlation of the Density, Viscosity and Vapor Pressure of Fatty Acid 2-Ethyhexyl Esters

Micro-Phase Separation Structure PU Membranes for Pervaporation of n-Butanol/Water Mixtures

A non-aqueous phase extraction system using tributyl phosphate for H3PO4 separation from wet-process superphosphoric acid: Extraction equilibrium and mechanism

Experimental Measurements and Molecular Simulations on the Liquid Density and Viscosity of Pentaerythritol Tetraacetate

Extraction Equilibria of Formic and Acetic Acids from Aqueous Solution by Phosphate-Containing Extractants

Isobutane/Butene Alkylation on Supported Phosphotungstic Acid Promoted by Hexadecylphosphate

Density and Viscosity Measurements on the Ternary System of Exo-Tetrahydrodicyclopentadiene (1) + N-Decane (2) + Iso-Butanol (3) and Corresponding Binary Systems

Densities and Viscosities for the Ternary Mixtures of n-Undecane (1) + Butylcyclohexane (2)+1-Pentanol (3) and Corresponding Binaries at T = (293.15 to 333.15) K