Two-Phase improves Bio-hydrogen and Bio-methane production of anaerobic membrane bioreactor from waste activated sludge with digestate recirculation
Wanjiang Li,Teng Cai,Xueqin Lu,Yule Han,Dilibaierkezi kudisi,Guohua Chang,Ke Dong,Guangyin Zhen
DOI: https://doi.org/10.1016/j.cej.2022.139547
IF: 15.1
2022-10-08
Chemical Engineering Journal
Abstract:The conventional recirculated two-phase anaerobic digestion (R-TPAD) equipped with two continuous stirred tank reactors (CSTR) usually shows poor water quality, insufficient bioconversion degree and low methane productivity. In this study, a new R-TPAD with CSTR as acidogenic phase and anaerobic membrane reactor (AnMBR) as methanogenic phase was constructed to digest waste activated sludge (WAS) for renewable energy recovery (H 2 and CH 4 ). The effects of recirculation ratio (R) on start-up time, long-term performance, membrane fouling behaviors, microbial community evolution, and energy recovery efficiencies were investigated systematically. Result showed that the R-TPAD possessed high H 2 (6.1 mL/g-COD) and CH 4 (67.9 mL/g-COD) yields with the corresponding COD removal of up to 96.1% at R 0.2 . During the whole process, the transmembrane pressure was lower than −3.3 kPa with negligible membrane fouling observed. The 16S rRNA gene analysis revealed that the synergistic role of membrane separation and recirculation system promoted the proliferation of fatty acids-producing and organics-degrading bacteria (i.e. Coprothermobacteraeota , Bacteroidetes , etc.) in acidogenic phase and CH 4 -producing methanogens (i.e. Methanobacterium , Methanosaeta , etc.) in methanogenic phase, thus accelerating the biodegradation of WAS. This positive stimulation sustained the high diversity and the dynamic balance of key microorganisms in the R-TPAD process. Energy balance analysis further indicated that the R-TPAD with R 0.2 could increase net energy output by 77.9% compared to the control TPAD without recirculation. This work provides a fundamental data base for the scientific management of WAS and push forward the real-world application of R-TPAD technology in the real-world scenarios.
engineering, chemical, environmental