Abstract:The conventional recirculated two-phase anaerobic digestion (R-TPAD) equipped with two continuous stirred tank reactors (CSTR) usually shows poor water quality, insufficient bioconversion degree and low methane productivity. In this study, a new R-TPAD with CSTR as acidogenic phase and anaerobic membrane reactor (AnMBR) as methanogenic phase was constructed to digest waste activated sludge (WAS) for renewable energy recovery (H 2 and CH 4 ). The effects of recirculation ratio (R) on start-up time, long-term performance, membrane fouling behaviors, microbial community evolution, and energy recovery efficiencies were investigated systematically. Result showed that the R-TPAD possessed high H 2 (6.1 mL/g-COD) and CH 4 (67.9 mL/g-COD) yields with the corresponding COD removal of up to 96.1% at R 0.2 . During the whole process, the transmembrane pressure was lower than −3.3 kPa with negligible membrane fouling observed. The 16S rRNA gene analysis revealed that the synergistic role of membrane separation and recirculation system promoted the proliferation of fatty acids-producing and organics-degrading bacteria (i.e. Coprothermobacteraeota , Bacteroidetes , etc.) in acidogenic phase and CH 4 -producing methanogens (i.e. Methanobacterium , Methanosaeta , etc.) in methanogenic phase, thus accelerating the biodegradation of WAS. This positive stimulation sustained the high diversity and the dynamic balance of key microorganisms in the R-TPAD process. Energy balance analysis further indicated that the R-TPAD with R 0.2 could increase net energy output by 77.9% compared to the control TPAD without recirculation. This work provides a fundamental data base for the scientific management of WAS and push forward the real-world application of R-TPAD technology in the real-world scenarios.

Two-phase Anaerobic Co-Digestion of Food Waste and Sewage Sludge.

Comparison of High-Solids to Liquid Anaerobic Co-Digestion of Food Waste and Green Waste

Thermophilic-mesophilic temperature phase anaerobic co-digestion compared with single phase co-digestion of sewage sludge and food waste

Temperature-phased Anaerobic Co-Digestion of Food Waste and Paper Waste with and Without Recirculation: Biogas Production and Microbial Structure.

The Influence of Aerobic Sludge Retention Time on Anaerobic Co-Digestion of Dyeing and Printing Wastewater and Sewage Sludge

Two-Phase improves Bio-hydrogen and Bio-methane production of anaerobic membrane bioreactor from waste activated sludge with digestate recirculation

Performance and Microbial Community Evaluation of Full-Scale Two-Phase Anaerobic Digestion of Waste Activated Sludge.

Temperature-phased Anaerobic Digestion of Food Waste: A Comparison with Single-Stage Digestions Based on Performance and Energy Balance.

Pilot-scale two-phase anaerobic digestion of deoiled food waste and waste activated sludge: Effects of mixing ratios and functional analysis

Anaerobic Co-Digestion of Food Waste and Sewage Sludge in Anaerobic Sequencing Batch Reactors with Application of Co-Hydrothermal Pretreatment of Sewage Sludge and Biogas Residue

The Influence and Mechanism of Influent Ph on Anaerobic Co-Digestion of Sewage Sludge and Printing and Dyeing Wastewater

A New Method of Two-Phase Anaerobic Digestion for Fruit and Vegetable Waste Treatment.

Optimisation of anaerobic co-digestion in two-stage systems for hydrogen, methane and biofertiliser production

Development of an alkaline/acid pre-treatment and anaerobic digestion (APAD) process for methane generation from waste activated sludge

Anaerobic Co-Digestion of Food Waste with Sewage Sludge: Simulation and Optimization for Maximum Biogas Production

A Half-Submerged Integrated Two-Phase Anaerobic Reactor for Agricultural Solid Waste Codigestion

Co-digestion of Wheat Straw and Fruit / Vegetable Waste by Using an Innovative Integrated Two-phase Anaerobic Reactor

Hydrogen and Methane Production in a Two-Stage Thermophilic Anaerobic Digestion System by Co-Digestion of Kitchen Waste and Municipal Sewage Sludge with a High Solid Content

Enhanced hydrolysis and methane yield of temperature-phased dewatered sludge anaerobic digestion by microbial electrolysis cell

Efficient acetogenesis of anaerobic co-digestion of food waste and maize straw in a HSAD reactor

Enhanced performance and economic feasibility of sewage sludge digestion using a two-stage anaerobic digestion with a dynamic membrane and alkaline-thermal pretreatment