Abstract:For coal semi-char as a by-produced of low-temperature pyrolysis, combustion for power generation is one of the effective utilization methods to realize its clean and efficient utilization. However, the coal semi-char combustion process has a difficult ignition, unstable combustion and low burnout rate. The co-firing of the semi-char with biomass under oxy-fuel conditions can improve the combustion behavior and reduce fossil CO2 emissions. In this paper, the combustion behavior of Shenhua coal semi-char (SHC) co-firing with straw (ST) in O2/CO2 mixture is investigated using thermogravimetric analysis. The results show that each curve lays between those of the individual fuels and presents three peaks (i.e., three stages). The thermogravimetric curves of SHC co-firing with ST can be divided into three stages: the volatile combustion of ST, the co-combustion of SHC and ST fixed-carbons and the SHC fixed-carbon combustion and the decomposition of the difficult pyrolytic material of ST. Blending ST into the SHC can significantly decrease the ignition temperature and improve the comprehensive combustion behavior of blended samples. In increasing the proportion of ST from 25 to 100%, the change of the blended ignition temperature is slight, but the burnout temperature decreases greatly. Kinetic parameters of combustion are calculated by using the Coats–Redfern integral method. Compared to that of stage I and stage III, the activation energy of stage II is significantly lower. As increasing blending ratio from 25% to 100%, the activation energy increases at stage I and decreases at stage III. Furthermore, the O2 concentration obviously affects stage III of 50% SHC + 50% ST, and the thermogravimetric curves at this stage are obviously shifted to the lower temperature zone as the O2 concentration increases. The activation energy of 50% SHC + 50% ST increases as the oxygen concentration increases. Besides, the activation energy shows that the combustion characteristics cannot be determined only by the activation energy obtained by the Coats–Redfern method. These findings can provide useful information for semi-char co-firing with biomass.

Co-Combustion Characteristics of Oil Shale Semi-Coke and Corn Stalk

Experimental Study on Pyrolysis and Combustion Properties of Biomass Briquette.

Co-combustion Characteristics and CO2 Emissions of Low-Calorific Multi-Fuels by TG-FTIR Analysis

Combustion kinetics study of oil shale semi-coke

Thermogravimetric Analysis of Coal Semi-Char Co-Firing with Straw in O2/CO2 Mixtures

Study of the combustion mechanism of oil shale semicoke in a thermogravimetric analyzer

STUDY ON COMBUSTION PROPERTY OF MIXTURE OF OIL SHALE AND HESHAN COAL

Co-combustion of Coal and Carbonaceous Wastes: Thermogravimetric Analysis

Co-combustion of furfural residue waste and oil shale: characteristics, synergistic effects, kinetics, and optimization analysis

Co-combustion of pulverized coal and walnut shells in air and oxy-fuel atmospheres: Thermal behavior, synergistic effect and kinetics

Experimental study on co-firing characteristics of coal/biomass blends in O2/CO2 atmosphere

Investigation on co-combustion of semi-coke and bituminous coal in oxygen-enriched atmosphere: Combustion, thermal conversion, and kinetic analyses

Co-Combustion Characteristics of Typical Biomass and Coal Blends by Thermogravimetric Analysis

Experimental investigation on co-combustion characteristics of semi-coke and coal: Insight into synergy and blending method

Investigation on the co-combustion of oil shale and municipal solid waste by using thermogravimetric analysis

Investigation on the co-combustion characteristics of multiple biomass and coal under O2/CO2 condition and the interaction between different biomass.

Structure characteristics and combustion kinetics of the co-pyrolytic char of rice straw and coal gangue

Thermal Behavior and Gas Evolution Characteristics During Co-Pyrolysis of Lignocellulosic Biomass and Coal: A TG-FTIR Investigation

Two-dimensional Combustion Modelling and Experimental Research on Oil Shale Semicoke

Experimental investigation on ignition and burnout characteristics of semi-coke and bituminous coal blends

The Investigation of Co-Combustion Characteristics of Tobacco Stalk and Low Rank Coal Using a Macro-Tga