Abstract:To accommodate the integration of renewable energy, coal-fired power plants must take on the task of peak regulation, making the low-load operation of boilers increasingly routine. Under low-load conditions, the phase transition point (PTP) of the working fluid fluctuates, leading to potential flow instability, which can compromise boiler safety. In this paper, a one-dimensional coupled dynamic model of the combustion and hydrodynamics of a supercritical boiler is developed on the Modelica/Dymola 2022 platform. The spatial distribution of key thermal parameters in the furnace and the PTP position in the water-cooled wall (WCW) are analyzed in a 660 MW supercritical boiler when parameters on the combustion side change under full-load and low-load conditions. The dynamic response characteristics of the temperature, mass flow rate, and the PTP position are investigated. The results show that the over-fire air (OFA) ratio significantly influences the flue gas temperature distribution. A lower OFA ratio increases the flue gas temperature in the burner zone but reduces it at the furnace exit. The lower OFA ratio leads to a higher fluid temperature and shortens the length of the evaporation section. The temperature difference in the WCW outlet fluid between the 20% and 60% OFA ratios is 11.7 °C under BMCR conditions and 7.4 °C under 50% THA conditions. Under the BMCR and 50% THA conditions, a 5% increase in the coal caloric value raises the flue gas outlet temperature by 32.7 °C and 35.4 °C and the fluid outlet temperature by 6.5 °C and 9.9 °C, respectively. An increase in the coal calorific value reduces the length of the evaporation section. The changes in the length of the evaporation section are −2.95 m, 2.95 m, −2.62 m, and 0.54 m when the coal feeding rate, feedwater flow rate, feedwater temperature, and air supply rate are increased by 5%, respectively.

Dynamic Simulation Model of 300MW Oxy-Combustion of Pulverized Coal Boiler

Pulverizing System Simulation Model of a 300MW Oxy-Fuel Coal Fired Boiler

Dynamic modeling and control for pulverized-coal-fired oxy-combustion boiler island

Numerical Investigation on Oxy-Combustion Characteristics of a 200 MWe Tangentially Fired Boiler

Study on coal combustion characteristics in a 350MW supercritical tangentially boiler

Modeling of a 300 MW Circulating Fluidized Bed Boiler

Simulation of Dynamic Characteristics of Supercritical Boiler Based on Coupling Model of Combustion and Hydrodynamics

Dynamic Modeling and Simulation of CFB Boiler

Development of Dynamic Simulation Platform for CFBC Boiler

Coal-fired power plant boiler combustion process modeling based on support vector machine and load data division

Numerical Simulation of O2／CO2 Recycled Flue Gas Combustion in a 300 MW Boiler

Dynamic performance analysis and control strategy optimization for supercritical coal-fired boiler: A dynamic simulation

Numerical Simulation of Combustion and Pollution in a 330MW Opposed Firing Boiler

Numerical Investigation of Swirl-Stabilized Pulverized Coal Flames in Air and Oxy-Fuel Atmospheres by Means of Large Eddy Simulation Coupled with Tabulated Chemistry

Simulation of Turbulent Combustion in a Large Pulverized Coal Boiler Based on Turbulent Radiation Interaction and the Modified Soot Model

Study on the Dynamic Characteristics of a 600MW Supercritical Once-Through Boiler

Modeling and Simulation of the Long-term Dynamic Characteristics of a Supercritical Once-through Boiler

STUDY ON DYNAMIC MATHEMATICAL MODEL AND SIMULATION OF CFB BOILER

Combustion Modeling Of Cfb Boiler Furnace Based On An Euler-Euler Approach

Modelica-based heating surface modelling and dynamic exergy analysis of 300 MW power plant boiler

Prediction on pulverized coal combustion process in the boiler using computer simulation