Abstract:To accommodate the integration of renewable energy, coal-fired power plants must take on the task of peak regulation, making the low-load operation of boilers increasingly routine. Under low-load conditions, the phase transition point (PTP) of the working fluid fluctuates, leading to potential flow instability, which can compromise boiler safety. In this paper, a one-dimensional coupled dynamic model of the combustion and hydrodynamics of a supercritical boiler is developed on the Modelica/Dymola 2022 platform. The spatial distribution of key thermal parameters in the furnace and the PTP position in the water-cooled wall (WCW) are analyzed in a 660 MW supercritical boiler when parameters on the combustion side change under full-load and low-load conditions. The dynamic response characteristics of the temperature, mass flow rate, and the PTP position are investigated. The results show that the over-fire air (OFA) ratio significantly influences the flue gas temperature distribution. A lower OFA ratio increases the flue gas temperature in the burner zone but reduces it at the furnace exit. The lower OFA ratio leads to a higher fluid temperature and shortens the length of the evaporation section. The temperature difference in the WCW outlet fluid between the 20% and 60% OFA ratios is 11.7 °C under BMCR conditions and 7.4 °C under 50% THA conditions. Under the BMCR and 50% THA conditions, a 5% increase in the coal caloric value raises the flue gas outlet temperature by 32.7 °C and 35.4 °C and the fluid outlet temperature by 6.5 °C and 9.9 °C, respectively. An increase in the coal calorific value reduces the length of the evaporation section. The changes in the length of the evaporation section are −2.95 m, 2.95 m, −2.62 m, and 0.54 m when the coal feeding rate, feedwater flow rate, feedwater temperature, and air supply rate are increased by 5%, respectively.

Study on the Dynamic Characteristics of a 600MW Supercritical Once-Through Boiler

Modeling and Simulation of the Long-term Dynamic Characteristics of a Supercritical Once-through Boiler

Study on coal combustion characteristics in a 350MW supercritical tangentially boiler

Simulation of Dynamic Characteristics of Supercritical Boiler Based on Coupling Model of Combustion and Hydrodynamics

A dynamic mathematical model used for controller design of a supercritical once-through boiler-turbine unit in all load conditions

Heat Transfer in Furnace of 1 000 MW Coal-fired Unit under Different Load Conditions

Dynamic Behavior of Steam Temperature of Supercritical Thermal Power Units

STUDY ON DYNAMIC MATHEMATICAL MODEL AND SIMULATION OF CFB BOILER

A Composite Nonlinear Control Scheme of the Ultra-Supercritical Boiler-Turbine Unit for Large-Scale Load Accommodation

Large Eddy Simulation of a 660 MW Utility Boiler under Variable Load Conditions

Dynamic performance analysis and control strategy optimization for supercritical coal-fired boiler: A dynamic simulation

Integrated Numerical Model for Ultra/Supercritical CFB Boilers

Performance Analysis Platform of Supercritical Power Station Boilers Based on the Fluid Network Method

Steam Temperature Characteristics in Boiler Water Wall Tubes Based on Furnace CFD and Hydrodynamic Coupling Model

Long-term Dynamic Model and Simulation of Steam Turbines

Long-term Dynamic Characteristics Model of a Power Plant Thermodynamic System

Development and validation of a dynamic flowsheet model for a 350 MWe supercritical circulating fluidized bed boiler

Dynamic Simulation of MFT and BT Processes on a 660 MW Ultra-Supercritical Circulating Fluidized Bed Boiler

Study on Nonlinear Control Model of Supercritical (Ultra Supercritical) Circulating Fluidized Bed Unit

A Dynamic Mathematical Model for Wide-Load Range Operation of Ultra-Supercritical Units

Experimental test, numerical analysis and thermal calculation modeling of hundreds kW th -class supercritical CO 2 fossil-fired boiler system