Abstract:Strategies to change the properties of metallic glass by controlling the crystallization and the glass transition behavior are essential in promoting the application of these materials. Aside from changing the composition approaches to stabilize the glass and frustrate the nucleation and growth of crystals, new strategies at a fixed glass composition are of special interest. In this review, some recent work is summarized on new strategies to tune the properties of metallic glasses without changing composition. First, the nanocrystallization strategy is introduced that is based on the nanocrystallized microstructures such as those that develop in marginal Al-based metallic glasses. The heterogeneous and transient nucleation effects in the nanocrystallization reactions in Al-based metallic glasses are systematically investigated and can be assessed by the determination of delay time based on Flash DSC measurements. These results provide a basis to understand the strong effect of minor alloying additions on the onset of primary Al nanocrystallization and to design the novel Al-based composites with improved properties. Secondly, by an optimal annealing treatment, a liquid-cooled Au-based metallic glass can achieve very high kinetic stability to yield a large increase in glass transition temperature of 28 K and this is 3-5 times larger than the increase usually reported. The measured enthalpy decrease is about 50% of the difference between the as-cooled glass and the equilibrium crystalline state and reaches the extrapolated enthalpy of the supercooled liquid. Finally, the nano-glass strategy makes an Au-based nanoglass show ultrastable kinetic characters at low heating rate (e.g., 300 K/s) compared to a melt-spun ribbon, which is attributed to the kinetic constraint effect of nanoglobular interfaces. These results indicate that the nanoglass microstructure can act to increase metallic glass stability and provide another mechanism for the synthesis of ultrastable glass. These developments open new opportunities to improve the stability and properties and largely increase the application potentials of metallic glasses.

Glass-Transition Process in an Au-Based Metallic Glass

Activation energy spectrum for relaxation and polyamorphism in an ultra-viscous metallic glass former

Observation of an isothermal glass transition in metallic glasses

Structural Behavior of Pd40Cu30Ni10P20 Bulk Metallic Glass below and above the Glass Transition

IDENTIFYING THE GLASS TRANSITIONS IN Al85Ni5Y6-Fe2Co2 METALLIC GLASS USING TEMPERATURE MODU-LATED DIFFERENTIAL SCANNING CALORIMETRY

Structural transformation and rheological processes in bulk metallic glass Zr41Ti14Cu12.5Ni10Be22.5

Critical behavior of the fluctuation heat capacity near the glass transition of metallic glasses

In situ scattering study of multiscale structural evolution during liquid–liquid phase transition in Mg-based metallic glasses

Nanoglass and Nanocrystallization Reactions in Metallic Glasses

Atomic Dynamics Transition in a Cu-Zr-Al Metallic Glass

Crystallization Kinetics in Cu35ag15zr45al15 Metallic Glass

Diffusion in metallic glasses and supercooled melts

Low-density to high-density transition in Ce75Al23Si2 metallic glass.

Cooling rate dependence and local structure in aluminum monatomic metallic glass

Kinetics of non-isothermal crystallization in Cu50Zr43Al7 and (Cu50Zr43Al7)95Be5 metallic glasses

Decoupling between calorimetric and dynamical glass transitions in high-entropy metallic glasses

Microstructure and crystallization in Cu50Zr45Al5 metallic glass

Unveiling the time-temperature dependence of metastability of supercooled liquid using nano-calorimetry

Simulation of Cu-Mg metallic glass: Thermodynamics and Structure

Observation of an apparent first-order glass transition in ultrafragile Pt–Cu–P bulk metallic glasses

Influence of silver introduction on glass-transition and crystallization processes in As40Se30Te30 glass