Abstract:This paper presents the results of a study on removal of Pb 2+ ions by using hydroxyapatite (HAP) scaffold prepared by replication method. To this aim, the effects of suspension solid content and polymeric foam density on the properties of ceramic foam were investigated. The mean total porosity and apparent porosity of the optimized scaffolds were 92.67 % and 92.04 %, respectively. The Taguchi method was performed for designing batch experiments by considering three controllable variables, namely: (1) initial pH of the solution, (2) initial concentration of Pb 2+ ions (C 0 ), and (3) circulating rate of the solution (Ǭ), on the removal efficiency of Pb 2+ ions as the response. Based on the obtained results from the ANOVA analysis, the removal efficiency of Pb 2+ ions was mainly affected by the initial pH of the solution (90.88 %). The highest removal efficiency (99.1 %) of Pb 2+ ions was obtained by optimizing the process under operating conditions of pH = 3.5, C 0 = 50 mg.L −1 , and Ǭ= 0.5 L.min −1 . The Langmuir isotherm model with good accuracy was fitted to the equilibrium results, and the maximum adsorption capacity of 106.38 mg.g −1 was predicted for the HAP scaffold adsorbent. Kinetic studies showed that the mass transfer diffusion steps in the external film and inside the pores are fast, being the adsorption on the adsorbent sites the rate-limiting step of the kinetics, what is plausible given the high porosity of the material. Also, the primary mechanism for Pb 2+ adsorption using HAP scaffold adsorbents was found to be dissolution-precipitation. The fixed-bed column adsorption experiments performed under the predicted optimum conditions of batch experiments. In comparison to the powder adsorbents tested in fixed-bed column, this adsorbent presents several advantages. These include the elimination of the requirement for mechanical separation of the shaped adsorbent from the solution after adsorption, prevention of bed clogging, and its high surface area derived from interconnected open pores.

Synthesis of Rod-Like Hydroxyapatite with High Surface Area and Pore Volume from Eggshells for Effective Adsorption of Aqueous Pb(II)

Adsorption of Pb (II) Ions onto Hydroxyapatite Nanopowders in Aqueous Solutions

Preparation of Porous Hydroxyapatite Using Cetyl Trimethyl Ammonium Bromide as Surfactant for the Removal of Lead Ions from Aquatic Solutions

Strontium-doped hydroxyapatite as adsorbent effectively to remove lead ions from water

Alkali-treated Yttrium-Containing Chitosan-Based Hydrogels for Phosphate Recover with Highly Selective in Wide Ph Aqueous Solution

Alkali-Treated Yttrium-Containing Chitosan-Based Hydrogel Beads for Phosphate Removal from Aqueous Solutions

Preparation of novel porous hydroxyapatite sheets with high Pb2+ adsorption properties by self-assembly non-aqueous precipitation method

A facile microwave-assisted synthesis of mesoporous hydroxyapatite as an efficient adsorbent for Pb2+ adsorption

The preparation of calcium phosphate adsorbent from natural calcium resource and its application for copper ion removal

Performance of oxalate-doped hydroxyapatite as well as relative contribution of oxalate and phosphate for aqueous lead removal

Natural hydroxyapatite powder from pig-bone waste (pHAP) for the rapid adsorption of heavy metals (Cu) in aqueous solution

Preparation of hydroxyapatite nanostructures with different morphologies and adsorption behavior on seven heavy metals ions

Acid precipitation-hydrothermal synthesis of needle-like hydroxyapatite for protein adsorption from waste phosphogypsum

Surface and mass transfer kinetic and equilibrium modeling of Pb(II) ions adsorption on hydroxyapatite scaffold: Batch and fixed-bed column studies

Bioinspiration synthesis of hydroxyapatite nanoparticles using eggshells as a calcium source: Evaluation of Congo red dye adsorption potential

Facet-Controlled Growth of Hydroxyapatite for Effectively Removing Pb from Aqueous Solutions

Optimization of Pb(II) ions adsorption on nanohydroxyapatite adsorbents by applying Taguchi method

Characterization of nano-hydroxyapatite synthesized from eggshells for absorption of heavy metals

Synthesis and physicochemical evaluation of hydroxyapatite gel biosorbent for toxic Pb(II) removal from wastewater

Characterization of Lead Uptake by Nano-Sized Hydroxyapatite: A Molecular Scale Perspective

Some Factors Affecting the Removal of Lead(II) Ions from Aqueous Solution by Porous Calcium Hydroxyapatite: Relationships between Surface and Adsorption Properties