Abstract:The flow condensation heat transfer coefficient of R134a inside two helical micro-fin tubes with outer diameter of 6.35 mm and helical angles of 18o and 28o respectively were experimentally studied at a high mass flux ranging from 500 to 1100 kg m−2 s−1. The condensation temperatures are 35°C, 40°C and 45°C, and the vapor qualities ranges from 0.95 to 1.00 at the inlet section and from 0.00 to 0.05 at the outlet section. Experimental results show that there are annular and intermittent flow regimes inside the tube under experimental conditions, the ratio of annular flow region to the total heat transfer region is about 70%. The liquid film flow changes from rotational flow to coexistence of rotational and horizontal flows when the vapor quality is 0.475±0.08, 0.486±0.06 and 0.521±0.05, respectively and the corresponding saturation temperature is 35°C, 40°C and 45°C. Based on the experimental data, the heat transfer coefficient increases with increasing mass flux and fin helical angle, and with decreasing saturation temperature and Reynolds number of cooling water. In addition, the heat transfer coefficient of annular flow is greater than that of intermittent flow, in other words, the heat transfer coefficient increases with increasing vapor quality. The heat transfer coefficient obtained at high mass flux was compared with the calculated data of some published correlations used at low mass flux. It was found that most correlations underestimate the experimental heat transfer coefficient inside the micro-fin tube, and these prediction deviation increases with increasing mass flux and fin helical angle. By introducing some dimensionless numbers as well as considering the flow mechanism of liquid film inside the tube, two heat transfer coefficient correlations were proposed based on the experimental data. The ratio of liquid film thickness to fin height was used to characterize whether the liquid film flow is rotational flow or coexistence of rotational and horizontal flows in the proposed correlation, which shows a better prediction accuracy with a mean deviation of less than 7.3%.

New experimental data of CO 2 flow boiling in mini tube with micro fins of zero helix angle

Investigation of Flow Boiling Heat Transfer Characteristics of CO2in Horizontal Mini-Tube

Characteristics of Heat Transfer for CO2 Flow Boiling at Low Temperature in Mini-Channel

Study of Heat Transfer for Co2 Flow Boiling in Horizontal Small Diameter Tubes

Characteristics of Flow Boiling Heat Transfer of Sub-Critical CO2 in Mini-Channels with Micro-Fins

Influence Of 0 Degrees Helix Angle Micro Fins On Flow And Heat Transfer Of R32 Evaporating In A Horizontal Mini Multichannel Flat Tube

Experimental Study of Flow Boiling Instabilities in Horizontal Tubes under Gas–liquid Stratification Condition: Effects of Heat Flux and Inlet Subcooling Degree

Experimental Study of Condensation Heat Transfer of R134a Inside the Micro-Fin Tubes at High Mass Flux

Characteristics of Heat Transfer for CO2 Flow Boiling in Mini_channel

Experimental investigation on heat transfer of subcooled flow boiling of water in mini channels under high heat fluxes

Experimental Study on Flow Boiling Heat Transfer of High-Pressure Water in Microtube with Coiled Wire Inserted

Numerical simulation on flow boiling heat transfer of CO2/propane mixture in tubes with/without micro-fins

Numerical Investigation on R32 Flow Boiling in Smooth Mini-Tube

Experimental Study of Flow Boiling Heat Transfer in Mini-Tube

A numerical study of microtube geometry effect on flow boiling using the volume of fluid method

Enhancement of Flow Boiling Heat Transfer in Microchannel Using Micro-Fin and Micro-Cavity Surfaces

Numerical Investigation of Subcooled Flow Boiling in an Inclined Rectangular Mini-Channel at a Low Flow Rate

Flow boiling of liquid nitrogen in micro-tubes: Part II – Heat transfer characteristics and critical heat flux

Flow Boiling Heat Transfer Characteristics on Micro-Pin-finned Surfaces in a Horizontal Narrow Microchannel

Experimental Study Of Boiling Heat Transfer Of Subcritical Co2 In Horizontal Small Diameter Tubes

Experimental Investigation on Flow Boiling of Hfe-7100 in a Microchannel with Pin Fin Array