Abstract:Thermal transport by phonons in films with thicknesses of less than 10 nm is investigated in a soft system (Lennard-Jones argon) and a stiff system (Tersoff silicon) using two-dimensional lattice dynamics calculations and the Boltzmann transport equation. This approach uses a unit cell that spans the film thickness, which removes approximations related to the finite cross-plane dimension required in typical three-dimensional-based approaches. Molecular dynamics simulations are performed to obtain finite-temperature structures for the lattice dynamics calculations and to predict thermal conductivity benchmarks. Thermal conductivity decreases with decreasing film thickness until the thickness reaches four unit cells (2.1 nm) for argon and three unit cells (1.6 nm) for silicon. With a further decrease in film thickness, thermal conductivity plateaus in argon while it increases in silicon. This unexpected behavior, which we identify as a signature of phonon confinement, is a result of an increased contribution from low-frequency phonons, whose density of states increases as the film thickness decreases. Phonon mode-level analysis suggests that confinement effects emerge below thicknesses of ten unit cells (5.3 nm) for argon and six unit cells (3.2 nm) for silicon. Thermal conductivity predictions based on the bulk phonon properties combined with a boundary scattering model do not capture the low thickness behavior. To match the two-dimensional lattice dynamics and molecular dynamics predictions for larger thicknesses, the three-dimensional lattice dynamics calculations require a finite specularity parameter that in some cases approaches unity. These findings point to the challenges associated with interpreting experimental thermal conductivity measurements of ultrathin silicon films, where surface roughness and a native oxide layer impact phonon transport.

Thermal Conductivity of Confined Ultrathin Polymers

Phonon Confinement and Transport in Ultrathin Films

Raman Scattering Characterization of Transparent Thin Film for Thermal Conductivity Measurement

Thermal Influence on Excimer-Laser-induced Electrical Conductivity on Polyimide Film Surfaces

Measurement of the Thermal Transport Properties of Dielectric Thin Films Using the Micro-Raman Method

Micro‐scale, In‐plane Thermal Conductivity of PEDOT:PSS Thin Films Measured by a Suspended Membrane Device

Out-of-plane transient thermal conductivity measurements for bulk semiconducting conjugated polymers using fast scanning calorimetry

Thermal characterization of thin films: A chip-based approach for in-plane property analysis

Melt Expansion and Thermal Transitions of Semiconducting Polymers in Thin Films

Thermal conductivity measurement of submicrometer-scale silicon dioxide films by an extended micro-Raman method

Thickness Dependence of Glass Transitions Measured by AC-Chip Calorimetry in Films with Controlled Interface

Cross-plane Thermal Conductivity and Thermal Diffusivity Measurement in Thin-Films by One-Dimensional Thermal Wave Method

Measurement of in-plane thermal conductivity in polymer films

Anisotropic thermal diffusivity measurement of thin films: From a few to hundreds of microns

Measuring in-plane thermal conductivity of polymers using a membrane-based modified Ångström method

Thermal Conductivity of Polyvinylidene Fluoride Films with a Multi-Scale Framework

Size Effect On The Thermal Conductivity Of Ultrathin Polystyrene Films

Thermal conductivity measurement of polymers with an improved 3ω method

Measurement of in-plane thermal conductivity of self-suspended thin films

Determination on the thermal conductivity and thermal contact resistance of thin composite phase change films as a thermal interfacial material

Effect of Molecular Chain Architecture on Dynamics of Polymer Thin Films Measured by the Ac-Chip Calorimeter