Abstract:Zinc oxide (ZnO) films with thicknesses from (9.1 +/- 0.7) to (145 +/- 7) nm were deposited on silicon substrates by ion-assisted electron beam evaporation (EBE), and transformed to a highly (110)-oriented non-polar phase through thermal treatment at temperatures of 300, 500, and 700 degrees C. The structural, morphological and optical properties of the ZnO thin films were systematically characterized using transmission electron microscopy (TEM), X-ray diffraction (XRD), atomic force microscopy (AFM), spectroscopic ellipsometry (SE), and photoluminescence (PL). The XRD and AFM results illustrate that the deposited ZnO films evolved from an X-ray amorphous structure to the polycrystalline hexagonal wurtzite structure with increasing thickness and experienced a crystallographic plane improvement from (102) to the (110) non-polar phase during annealing. The dielectric functions of the whole layer are mainly affected by the dielectric responses near the surface of ZnO nanocrystals and show an upward trend with nanocrystal growth, induced by thickness and annealing temperature. The optical band gaps were also investigated and correlated with the structural properties. In the PL spectra, a strong ultraviolet luminescence (UVL) band and a weak visible green luminescence (GL) band were observed. The intensity ratio of UVL and GL-associated with crystal quality-agrees with the results acquired from other measurements. The two determinants for highly (110)-oriented non-polar ZnO films are the suppression of growth in the (002) direction by ion bombardment and the promotion of the (110) plane induced by diffusion energy during annealing. (C) 2017 Elsevier B.V. All rights reserved.

Microstructure Optimization and Optical Properties Modulation of Sputtering-Derived ZnO Thin Films

Microstructure and Optical Properties of ZnO Films Deposited by Radio-frequency Reactive Magnetron Sputtering

Effect of Annealing Temperature and CuO on Microstructure and Optical Band Gap of CuxZn1−xO Thin Films

Effect of Solution Concentrations on Crystal Structure, Surface Topographies and Photoluminescence Properties of ZnO Thin Films

Surface Topography and Optical Properties of Al-doped ZnO Thin Films by Sol-gel Process

Enhanced Visible Light Response of ZnO Porous Thin Film by Post-Annealing Treatment

Preparation and Characterization of Na-doped ZnO Thin Films by Sol–gel Method

Preparation and Characterization of Mg-doped ZnO Thin Films by Sol–gel Method

Influence of Annealing Atmosphere on Microstructure and Optical Properties of ZnO Thin Films

Annealing Effects on the Microstructure and Photoluminescence Properties of Ni-Doped Zno Films

Structural and Optical Properties of Highly (110)-Oriented Non-Polar ZnO Evaporated Films on Si Substrates

Deposition Condition Investigation of High c-axis Preferred Orientation ZnO Films Produced by RF Magnetron Sputtering

Influence of Postdeposition Annealing on Crystallinity of Zinc Oxide Films

Effect of sputtering power on the microstructure and photelectric properties of Al doped ZnO thin films

Structural and Optical Characterizations of ZnO Films Grown by Reactive Electron Beam Evaporation

MICROSTRUCTURE AND PROPERTIES OF ANNEALED ZnO THIN FILMS DEPOSITED BY MAGNETRON SPUTTERING

STRUCTURAL AND OPTICAL STUDIES OF ZnO FILMS GROWN AT LOW TEMPERATURE

Annealing effect on mechanical properties of RF magnetron sputtering ZnO thin film

Effects of Post-Annealing Treatment on the Structural and Optical Properties of Cubic Mg Chi Zn1-Chi O Thin Films Grown on Sapphire

Influences of Substrate and Annealing on the Structural and Optical Properties and Photoluminescence of Nanocrystalline Zno Films Prepared by Plasma Assisted Pulsed Laser Deposition

Microstructure and Electrical Properties of Al-doped ZnO Thin Films