Abstract:Exploration of efficient deep red phosphor based on non-rare-earth ion activated oxide is of great practical value in the field of phosphors converted white light-emitting diode lighting. A spinel Mg1+yAl2-xO4:xMn(4+), yMg(2+) phosphor with deep red emission is synthesized by a solid-state reaction route. The crystal structure and morphology are characterized by powder X-ray diffraction and scanning electron microscopy. The luminescent performance is characterized by fluorescence spectrophotometer and fluorescence decay curves. The results demonstrate that the synthesized phosphor shows that two excited spectrum bands centered at 290 nm and 438 nm cover a broad spectral region from 220 nm to 500 nm due to the Mn4+-O2- charge transfer band and the (4)A(2)-T-4(1) and T-4(2) transitions of Mn4+ ions. Upon excitation at 300 nm, a strong, narrow red emission band is observed between 600 and 700 nm peaked at 652 nm as a result of the spin-forbidden E-2(g)-(4)A(2g) electron transition of Mn4+. The corresponding chromaticity coordinate is (0.7256, 0.2854). Additionally, the concentration quenching of Mn4+ in the MgAl2O4 host is evaluated in detail, which indicates that the optimum doping concentration of Mn4+ is experimentally determined to be 0.14 mol%. The critical distance is calculated to be 52.15 angstrom according to the Blasse equation, which elucidates that the concentration quenching mechanism is consequently very likely to be induced by the multipole-multipole interaction. The crystal field strength (D-q) and the Racah parameters (B and C) are estimated to evaluate the nephelauxetic effect of Mn4+ suffered in MgAl2O4:Mn4+ host lattice. Luminous mechanism is explained by Tanabe-Sugano energy level diagram of Mn4+ ion. The ratio of Dq/B equals 1.74, indicating that Mn4+ ions experience a weak crystal field in the MgAl2O4 host and emission peak energy of E-2(g)-(4)A(2g) transition is dependent on the nephelauxetic effect. The red emission intensity of Mg1+yAl2-xO4:xMn(4+), yMg(2+) increases on account of excess Mg2+ which would compensate for the local charge balance surrounding Mn4+ ions, furthermore, lead the Mn4+-Mn4+ pairs connected with interstitial O2- to transform into isolated Mn4+ ions, and thus eliminating energy transfer and enhancing the luminescence efficiency effectively. The decay times of two time-dependent curves of Mg1+yAl2-xO4:xMn(4+), yMg(2+) are 0.672 ms and 0.604 ms, and each entire decay curve could be well-fitted to single-exponential, confirming that there is only a single Mn4+ ion luminescence center. The decay time of Mn 4 + luminescence is prolonged with the increase of Mg2+ content, indicating that excitation energy transfer and non-radiative relaxation between Mn4+-Mn4+ pairs decrease, the reason is that photoexcitation energy can be temporarily stored in the trapping centers induced by excess positive charges. These results imply that Mn4+ doped Mg1+yAl2-xO4:xMn(4+), yMg(2+) is a promising candidate of deep-red phosphors for near-UV and blue light emitting diodes. These findings in the paper would be beneficial not only to developing a low-cost and safe strategy to produce high-efficient Mn4+ activated luminescent materials for white light emitting diodes, but also to providing a new insight into improving the photoluminescence properties of Mn4+.

Preparation, Structural and Photoluminescence Characteristics of Novel Red Emitting Mg7ga2geo12:Mn4+ Phosphor

Insight into a Novel Rare-Earth-free Red-Emitting Phosphor Li3Mg2NbO6:Mn4+: Structure and Luminescence Properties

Enhanced Photoluminescence and Thermal Properties Due to Size Mismatch in Mg2TixGe1-xO4:Mn4+ Deep-Red Phosphors

Structure and Photoluminescence Properties of Rare-Earth Free Narrow-Band Red-Emitting Mg6zngega2o12: Mn4+ Phosphor Excited by Nuv Light

Mn 4+ -Doped Heterodialkaline Fluorogermanate Red Phosphor with High Quantum Yield and Spectral Luminous Efficacy for Warm-White-Light-Emitting Device Application.

Structural confinement-induced highly efficient deep-red emission and negative thermal quenching performance in Mn4+-activated Ca7Mg2Ga6−yAlyO18:Mn4+ phosphors

Preparation of Mg1+yAl2-xO4:xMn(4+), yMg(2+) deep red phosphor and their optical properties

Optical Characteristics, Morphology Evolution and Thermal Stability of Novel Red-Emitting Mn4+-activated K2LiAl1-yGayF6 Solid Solution Phosphors for High-Performance Warm WLED

Synthesis, optical characteristics and thermal stability of Mn4+-doped Na3GaF6 red-emitting phosphor for high-performance warm WLED

Photoluminescence Properties of a New Red-Emitting Mn-activated ZnGa2S4 Phosphor

Camg2al16o27:Mn4+-Based Red Phosphor: A Potential Color Converter for High-Powered Warm W-Led

A Novel Red Phosphor Mg2geo4 Doped with Eu3+ for Pdp Applications

Controlled Morphology, Improved Photoluminescent Properties, and Application of an Efficient Non-rare Earth Deep Red-Emitting Phosphor.

The electronic and optical properties of a narrow-band red-emitting nanophosphor K2NaGaF6:Mn4+ for warm white light-emitting diodes

A red-emitting Ca8MgLa(PO4)7:Ce3+,Mn2+ phosphor for UV-based white LEDs application

Efficient Rare-Earth Free Red -Emitting Ca2ysbo6: Mn4tm(M = Lit Nat Kt Mg21 Phosphors For White Light -Emitting Diodest

Novel Mn4+ Doped Red Phosphors Composed of MgAl2O4 and CaAl12O19 Phases for Light-Emitting Diodes.

Room-temperature synthesis, controllable morphology and optical characteristics of narrow-band red phosphor K2LiGaF6:Mn4+

Cation Substitution Induced Adjustment on Lattice Structure and Photoluminescence Properties of Mg 14 Ge 5 O 24 :Mn 4+ : Optimized Emission for w‐LED and Thermometry Applications

A Narrow-Band Red-Emitting K2LiGaF6:Mn4+ Phosphor with Octahedral Morphology: Luminescent Properties, Growth Mechanisms, and Applications

A Mn4+ Activated (gd,la)2(zn,mg)tio6 Deep-Red Emission Phosphor: the Luminescence Properties and Potential Application for Full-Spectrum Pc-Leds