Abstract:This study explores the phenomenon of slip transmission across grain boundaries in coarse-grained copper. The associated effects on the deformation gradient are also investigated, using both experiment and simulation. An in-situ tensile test of a fully annealed copper specimen was conducted first using a scanning electron microscope (SEM). The deformation gradient and geometrically necessary dislocation (GND) maps at selected tensile strain values were obtained and characterized by electron backscatter diffraction (EBSD). In addition, a physically based strain gradient crystal plasticity finite element method model has been developed to simulate the early stage of tensile deformation behaviour of copper. In this model, slip transmission across the grain boundary is either allowed or blocked, depending on the alignment of adjacent grains. Slip transmission is allowed at grain boundaries between suitably aligned grains according to the Luster-Morris factor, residual Burgers vector is applied to consider the slip misalignment at GB region, and dislocation accumulation at grain boundaries is included following the Kocks-Mecking law. It was found that dislocation pile-up, lattice rotation and stress concentration were much higher near the impenetrable grain boundaries than at the penetrable ones. Due to the slip transmissions across grain boundaries, the stress and strain concentrations can be partially relaxed, and the slip transmission induced relaxation is associated with the number of active slip systems and shear strain on the best aligned slip systems. This study provides an effective strategy to investigate the early stage of plastic deformation, and a good agreement between experimental observations and simulation results has been achieved.

Plastic Deformation in Al (cu) Interconnects Stressed by Electromigration and Studied by Synchrotron Polychromatic X-ray Microdiffraction

Comparison of the Time-Dependent Physical Processes in the Electromigration of Deep Submicron Copper and Aluminum Interconnects

High Strain Gradient Plasticity Associated with Wedge Indentation into Face-Centered Cubic Single Crystals: Geometrically Necessary Dislocation Densities

Electromigration-induced Stress in a Confined Bamboo Interconnect with Randomly Distributed Grain Sizes

Synchrotron X-Ray Microdiffraction Studies of Electromigration in Interconnect Lines at the Advanced Light Source

In Situ Measurement of Electromigration-Induced Transient Stress in Pb-free Sn–Cu Solder Joints by Synchrotron Radiation Based X-Ray Polychromatic Microdiffraction

Experimental and Crystal Plasticity Study on Deformation Bands in Single Crystal and Multi-Crystal Pure Aluminium

Characterization of electromigration-induced short-range stress development in Al(0.25 at. % Cu) conductor line

Investigation of Grain Subdivision at Very Low Plastic Strains in A Magnesium Alloy

Investigation of Plastic Yielding in Near-Micrometer Grain Size Aluminum Using Synchrotron Microdiffraction

Microscopic Heterogeneity of Plastic Strain and Lattice Rotation in Partially Recrystallized Copper Polycrystals

Evolution of Microstructure and its Parameters after Deformation of Polycrystalline Cu-Al Alloys with Different Stacking Fault Energy

In situ TEM study of microplasticity and Bauschinger effect in nanocrystalline metals

In Situ Synchrotron Study of Electromigration Induced Grain Rotations in Sn Solder Joints

Microhardness Distribution and Microstructural Evolution in Pure Aluminum Subjected to Severe Plastic Deformation: Elliptical Cross-Sectioned Spiral Equal-Channel Extrusion (ECSEE)

Probing microplasticity in small scale FCC crystals via Dynamic Mechanical Analysis

Dislocation-assisted grain growth in nanocrystalline copper under large deformation

In-situ Study of the Effect of Strain Path Change on Dislocation Boundary Evolution in Commercial Purity Aluminum

In-situ EBSD Study of the Active Slip Systems and Lattice Rotation Behavior of Surface Grains in Aluminum Alloy During Tensile Deformation

Electroplasticity mechanism study based on dislocation behavior of Al6061 in tensile process

An investigation of slip transmission during uniaxial tensile deformation of a coarse-grained copper via EBSD characterization and crystal plasticity modelling