Abstract:The melt of crystalline polymers normally crystalize on cooling and the polymer melts with low critical cooling rate would easily solidify as glass during cooling to their glass transition temperature ( T g ). The glassy process exhibits variety within each kind of polymer melts in the slope of the viscosity-temperature visibility, and the rate of the excess conformational entropy in the polymer melt over the crystalline phase changes in the T g approaching. Polytrimethylene terephthalate (PTT) and a series of polytrimethylene terephthalate copolyesters (PTTG) with different molar ratios of 1,3-propylene glycol (1,3-PDO) to 1,4-cyclohexanedimethanol (1,4-CHDM) were synthesized to modify the chain flexibility and the critical cooling rate. The glassy samples were obtained via quenching the melts of PTT and copolymers below the T g to characterize the cold crystallization behaviors. The evolutions of the crystalline structure of the amorphous samples were in situ investigated via DSC and simultaneous WAXS/SAXS approaches during heating. The polymer chain dynamics and the critical cooling rates of the PTT and copolymers were estimated by rheological testing and DSC characterization. The results indicate that the chain conformation adjustment of PTT and copolymers is relate to the comonomers in the copolymers, and the cold crystallization behaviors can be divided into three temperature ranges during heating. The first involves rapid transition from a pre-ordered phase to a crystalline phase, the second is the adjustment of defects in an imperfect crystalline phase, and the third may refer crystal reorganization before melting. The crystallization ability of the samples could be due to the ability of chain conformation adjustment with comonomer content till the crystallization is no longer obvious during heating. The cold crystallization behaviors of the samples were discussed based on the polymer chain dynamics and it is convinced that would be helpful to understand the crystallization and processing of polymers.

Structural Evolution Analysis and Cold-Crystallization Kinetics of Spherical Crystals in Poly(trimethylene Terephthalate) Film Using Raman Spectroscopy

Temperature-Dependent Triple Crystal Polymorphism of Poly(hexamethylene Terephthalate): Long-Range Ordered Mesophase Formation and Crystal Structure–Property Relationships

Evolution of Density Fluctuation to A Lamellar Crystal in A Poly(Trimethylene Terephthalate) Film Revealed by the Resonance Light Scattering Technique

Cold-Crystallization of Poly(trimethylene terephthalate) Studied by Photoluminescence of Its Amorphous Portion

Microstructure Evolution and Dynamic Stages of Cold‐Crystallized Poly(trimethylene Terephthalate) Revealed by Synchronous Fluorescence Scanning

Exploring time-dependent structural changes during the cold crystallization process of isotactic polystyrene by infrared spectroscopy and multivariate curve resolution.

Deformation Mechanisms of Polymer Thin Films by Simultaneous Kinetic Measurement of Microscopic Infrared Dichroism and Macroscopic Stress. Part Iii: Influence of Morphology on Molecular Orientation of Isotactic Polypropylene Films Subjected to Uniaxial Stretching

Multistage Structural Ordering and Crystallization of Poly(trimethylene Terephthalate) During Sub-Tg Stretching: Synergetic Effects of Chain Orientation and Conformational Transition

Crystallization Behavior and Morphology of Novel Aliphatic Poly (Monothiocarbonate)s

Cold crystallization of polytrimethylene terephthalate and copolymers

Structural Evolutions of the Amorphous Fraction of Polyethylene Terephthalate During the Secondary Crystallization

Morphology and crystal structure of CTFMP and bulk polymerized poly(trimethylene terephthalate)

A Novel Crystalline Structure ‐ Poly(tetrafluoroethylene) Spherulitic Crystal and Its Crystallization Kinetics

Oriented and Thermal Crystallization of Poly(Ethylene Terephthalate)

Poly(trimethylene teraphthalate) crystal structure and morphology in different length scales

Structural Evolution of Hard-Elastic Isotactic Polypropylene Film During Uniaxial Tensile Deformation: the Effect of Temperature

Structural evolution of cellulose triacetate film during stretching deformation: An in-situ synchrotron radiation wide-angle X-Ray scattering study

Non-isothermal Crystallization Behavior of Poly(ethylene Terephthalate)/poly(trimethylene Terephthalate) Blends

Monitoring Molecular Ordering of a Conjugated Polymer: PBTTT During Conformational Evolution

Interpretation of carbonyl band splitting phenomenon of a novel thermotropic liquid crystalline polymer without conventional mesogens: combination method of spectral analysis and molecular simulation.

Structural Changes During Isothermal Crystallization of A Poly(Bisphenol A-Co-Decane Ether) Polymer