Abstract:Compared to cross-linked polyethylene, polypropylene has a thermoplastic property and the advantage of recycling. However, the poor impact resistance at low temperature and the corresponding space charge problem restrict the application of polypropylene with the extruded high voltage direct current (HVDC) cable. Sufficient introduction of the β form of the polypropylene crystal can significantly improve impact resistance at low temperatures. Although it has been widely applied in insulation engineering, the effect of β-crystal on the space charge characteristics of polypropylene has rarely been researched until now. In this paper, a rare earth nucleating agent of β-crystal is employed to modify the performance of polypropylene to investigate the effects of nucleating agent content on β-crystalline, mechanical relaxation, trap, and space charge characteristics of polypropylene. The results of differential scanning calorimeter (DSC) and X-ray diffraction (XRD) tests indicate that the relative content of β-crystal in modified polypropylene increases gradually with the increasing concentration of the nucleating agent, approaching 43.5% when the nucleating agent content has been raised to 0.2 wt %, suggesting appreciable efficiency of the nucleating agent utilized in our research. Scanning electron microscopy (SEM) is utilized to characterize the morphology of β-crystal spherulites, which illustrates that the β-spherulites are in bunchy shape, and the lamellar crystals are parallel to each other without an obvious boundary between them. The results of the space charge test demonstrate that the modified polypropylene can substantially suppress space charge accumulation, which is attributed to an increment of β-crystal content by adopting a rare earth nucleating agent. It is indicated from dynamic mechanical analysis (DMA) measurements that the enhancement of β-crystalline in modified polypropylene can distinctly increase and decrease the β and α relaxation losses, respectively, which proves that the defects in β-crystal and amorphous regions are reduced and increased respectively. Thermally stimulated depolarization current tests further confirm that the number of traps caused by defects in the β-form of polypropylene crystal declines definitely, which dominantly accounts for the suppression of space charge accumulation.

Large Improvement in Trap Level and Space Charge Distribution of Polypropylene by Enhancing the Crystalline − Amorphous Interface Effect in Blends

Space Charge Suppression of Polyethylene Induced by Blending with Ethylene-Butyl Acrylate Copolymer

Graphene Enhanced Electrical Properties of Polyethylene Blends for High-Voltage Insulation

Dielectric Properties in Low Density Polyethylene Modified by Metallocene Catalyzed Polyethylene

Trap Distribution and Dielectric Breakdown of Isotactic Polypropylene/Propylene Based Elastomer With Improved Flexibility for DC Cable Insulation

Characterization of Polypropylene Modified by Blending Elastomer and Nano-Silica

Effect of Semiconductive Layer on Space Charge Accumulation of Polypropylene Blends for DC Cable Insulation

Enabling High-Performance Polypropylene Nanocomposites With Interfacial Deep Traps

Suppression of Elevated Temperature Space Charge Accumulation in Polypropylene/elastomer Blends by Deep Traps Induced by Surface-Modified ZnO Nanoparticles

Space Charge Characteristics of Polypropylene Modified by Rare Earth Nucleating Agent for β Crystallization

Space Charge Behavior in LDPE/EBA Insulation Materials for HVDC Cables

Electrical Property of Polypropylene Toughened by β Nucleating Agent

The Dielectric Properties Improvement of Cable Insulation Layer by Different Morphology Nanoparticles Doping into LDPE

Influence of Three-dimensional Boron Nitride Foam on Thermal Conductivity and Charge Transport Behavior for Polypropylene/Elastomer Blends

High Improvement In Trap Level Density And Direct Current Breakdown Strength Of Block Polypropylene By Doping With A Beta-Nucleating Agent

Electrical Properties of Polypropylene Copolymer/Polyolefin Elastomer/SiO2 Nanocomposites

Improvement of space charge suppression of polypropylene for potential application in HVDC cables

High improvement in trap level density and direct current breakdown strength of block polypropylene by doping with a β-nucleating agent

Relationship between space charge behaviors and trap level distribution in polypropylene/propylene ethylene rubber/ZnO nanocomposites

Study on Mechanism of Space Charge in Low Density Polyethylene Modified by Metallocene Catalyzed Polyethylene

Formation and Inhibition Mechanisms of Space Charges in Direct Current Polyethylene Insulation Explained by Energy Band Theory